Recombinant Mycobacterium bovis BCG Expressing Pertussis Toxin ...

2 downloads 0 Views 451KB Size Report
Since Mycobacterium bovis BCG vaccination against tuberculosis is used in most developing countries, a recombinant BCG-pertussis vaccine could be a more ...
INFECTION AND IMMUNITY, Sept. 2000, p. 4877–4883 0019-9567/00/$04.00⫹0 Copyright © 2000, American Society for Microbiology. All Rights Reserved.

Vol. 68, No. 9

Recombinant Mycobacterium bovis BCG Expressing Pertussis Toxin Subunit S1 Induces Protection against an Intracerebral Challenge with Live Bordetella pertussis in Mice IVAN P. NASCIMENTO,1,2 WALDELY O. DIAS,1 ROGERIO P. MAZZANTINI,1 ELIANE N. MIYAJI,1 MARCIA GAMBERINI,1 WAGNER QUINTILIO,1 VERA C. GEBARA,1 DIVA F. CARDOSO,3† PAULO L. HO,1 ISAIAS RAW,1 NATHALIE WINTER,4 BRIGITTE GICQUEL,4,5 RINO RAPPUOLI,6 AND LUCIANA C. C. LEITE1* Centro de Biotecnologia,1 and Immunopatologia,3 Instituto Butantan, and Departamento de Bioquı´mica, Instituto de Quı´mica, Universidade de Sa ˜o Paulo,2 Sa ˜o Paulo, Sa ˜o Paulo, Brazil; Laboratoire du BCG4 and Unite´ de Ge´ne´tique Mycobacte´rienne,5 Institut Pasteur, Paris, France; and IRIS, Chiron SpA, Siena, Italy6 Received 10 February 2000/Returned for modification 30 March 2000/Accepted 6 June 2000

The recent development of acellular pertussis vaccines has been a significant improvement in the conventional whole-cell diphtheria-pertussis-tetanus toxoid vaccines, but high production costs will limit its widespread use in developing countries. Since Mycobacterium bovis BCG vaccination against tuberculosis is used in most developing countries, a recombinant BCG-pertussis vaccine could be a more viable alternative. We have constructed recombinant BCG (rBCG) strains expressing the genetically detoxified S1 subunit of pertussis toxin 9K/129G (S1PT) in fusion with either the ␤-lactamase signal sequence or the whole ␤-lactamase protein, under control of the upregulated M. fortuitum ␤-lactamase promoter, pBlaF*. Expression levels were higher in the fusion with the whole ␤-lactamase protein, and both were localized to the mycobacterial cell wall. The expression vectors were relatively stable in vivo, since at two months 85% of the BCG recovered from the spleens of vaccinated mice maintained kanamycin resistance. Spleen cells from rBCG-S1PT-vaccinated mice showed elevated gamma interferon (IFN-␥) and low interleukin-4 (IL-4) production, as well as increased proliferation, upon pertussis toxin (PT) stimulation, characterizing a strong antigen-specific Th1-dominant cellular response. The rBCG-S1PT strains induced a low humoral response against PT after 2 months. Mice immunized with rBCG-S1PT strains displayed high-level protection against an intracerebral challenge with live Bordetella pertussis, which correlated with the induction of a PT-specific cellular immune response, reinforcing the importance of cell-mediated immunity in the protection against B. pertussis infection. Our results suggest that rBCG-expressing pertussis antigens could constitute an effective, low-cost combined vaccine against tuberculosis and pertussis. candidate as host for the presentation of heterologous antigens in the development of new live recombinant vaccines (13, 14). A multivalent vaccine based on recombinant BCG (rBCG) would have several advantages: (i) one dose would be sufficient to confer long-lasting cellular immunity; (ii) the World Health Organization recommends that BCG be administered at birth; (iii) it is the best-known adjuvant in animals and humans; and (iv) it has low production costs and is thermostable. Genes encoding immunodominant bacterial, viral, and parasitic antigens have been successfully expressed in BCG (1, 20, 25, 41, 42, 47). Although the expression levels of heterologous genes varied considerably with the expression vector and the gene used, many rBCG strains induced significant levels of humoral and/or cellular responses in vaccinated mice, some of which showed protection against challenge (1, 19, 25, 41). Recent developments in expression vectors have provided several options for the construction of rBCG strains based on different promoters and signal sequences. Besides the widely used hsp60 promoters (42, 47), pAN, pBlaF*, and the 18-kDa, 19-kDa and 85A antigen promoters, have been used to drive the expression of foreign genes (9, 19, 22, 43, 44, 46). The genes have been cloned under their native form or fused to mycobacterial exportation signals to direct the heterologous antigens to different BCG compartments. The upregulated M. fortuitum ␤-lactamase promoter, pBlaF*, has been shown to be much stronger than other promoters; when its signal sequence was included, exportation of the heterologous protein was observed (21, 43).

The whole-cell pertussis vaccine, as a component of the diphtheria-pertussis-tetanus toxoid (DPT) vaccine, has been shown to be very effective in protecting humans against Bordetella pertussis infection (35, 38). However, the reactogenicity of the whole-cell preparations (5) has led to resistance against vaccination campaigns, and some countries interrupted pertussis immunization, resulting in outbursts of pertussis infection (36). This stimulated the development of new acellular vaccines composed of one or more immunogenic components of the B. pertussis organism (24, 28, 35, 38). Several comparative studies on phase II efficacy trials have demonstrated that acellular pertussis vaccines are efficient and less reactogenic than the whole-cell DPT vaccine (12, 15). On the other hand, although acellular vaccines are a significant improvement on DPT vaccination, they still require multiple doses to achieve maximum efficiency and involve high-cost production. The development of a low-cost pertussis vaccine that immunizes efficiently with only one dose would be particularly important for developing countries, where difficult access to health centers hinders attaining complete vaccination of children. Mycobacterium bovis BCG is considered a high-potential * Corresponding author. Mailing address: Centro de Biotecnologia, Instituto Butantan, Av. Vital Brasil 1500, 05503-900 Sa˜o Paulo, SP, Brazil. Phone: 55-11-813-7222, ext. 2242. Fax: 55-11-815-1505. E-mail: [email protected]. † Deceased December 1999. 4877

4878

NASCIMENTO ET AL.

A pertussis vaccine based on rBCG could improve general immunization, since BCG can be administered at birth and requires only one dose to induce long-lasting immunity. Most developing countries use BCG for immunization against tuberculosis. rBCG expressing pertussis antigens could induce protective immunity against B. pertussis infection. Pertussis toxin (PT) is the most important antigen characterized so far for B. pertussis (45) and is a component of all approved and commercially available acellular vaccines (12, 15, 38). Its diverse activities in animals led it to be considered the main factor responsible for the clinical manifestations of pertussis infection, suggesting that PT would itself be a pertussis vaccine candidate (34). It is composed of five subunits; S1 is the active domain, and S2 to S5 arrange to form the binding domain (40). S1 has been shown to be immunogenic and protective in experimental animals (23, 29). The gene for the S1 subunit has been modified by site-directed mutagenesis to eliminate its toxic properties, generating PT-9K/129G (33). This gene has been used to produce a B. pertussis whole-cell vaccine containing nontoxic PT or to compose acellular DTP (DTaP) vaccines (27, 28). Here we show that a recombinant BCG strain expressing the S1 subunit of PT (S1PT) in fusion with the M. fortuitum ␤-lactamase signal sequence induces cellular and proliferative responses against PT and protects immunized mice against an intracerebral (i.c.) challenge with live B. pertussis. MATERIALS AND METHODS Animals and immunizations. Male 4-week-old Swiss or BALB/c mice (Instituto Butantan) were used for evaluation of the immune response against the rBCG strains. Mice were immunized intraperitoneally (i.p.) with 106 CFU/0.5 ml of BCG or rBCG strain expressing S1PT. Positive and negative controls were DPT (Butantan, Sa˜o Paulo, Sa˜o Paulo, Brazil) at 0.8 of the human dose and saline, respectively. The animals were bled at 2 weeks or every 4 weeks after the first dose. A booster was given to BALB/c mice at 10 weeks under the same conditions. Bacterial strains, growth conditions, and vaccine preparation. All cloning steps were performed in Escherichia coli DH5␣ grown in Luria-Bertani medium supplemented with ampicillin (100 ␮g/ml) or kanamycin (20 ␮g/ml). The M. bovis BCG Moreau strain was used to generate the rBCG strains. Liquid cultures of BCG strains were regularly grown in Middlebrook 7H9 medium supplemented with albumin-dextrose-catalase enrichment (Difco, Detroit, Mich.), with or without kanamycin (20 ␮g/ml) at 37°C, using stationary tissue culture flasks. The rBCG strains were cultured in Ungar’s medium (17) for the heterologous protein localization assays. BCG was transformed by electroporation as previously described (47) and plated onto Middlebrook 7H10 agar plates supplemented with oleic acid-albumin-dextrose-catalase enrichment (Difco) containing kanamycin (20 ␮g/ml). Plates were incubated at 37°C for 3 weeks before expansion of the transformed colonies in liquid media. rBCG vaccines were prepared from mid-log-phase liquid cultures of selected clones. The liquid cultures were centrifuged at 4,000 ⫻ g, resuspended in 50% glycerol–phosphate-buffered saline (PBS), and maintained frozen at ⫺80°C until used. Immediately before vaccination, cells were thawed and diluted in saline to reach the appropriate concentrations. Plasmid vectors. pUC18 was purchased from New England Biolabs (Beverly, Mass.). pUC-9K/129G, comprising the genetically detoxified PT gene cloned in the EcoRI site of pUC18, was generated as described previously (33). The mycobacterial expression vectors pLA71 and pLA73 were previously described (22). These vectors contain the E. coli and mycobacterium origins of replication, a kanamycin resistance gene, the upregulated M. fortuitum pBlaF*, its ATG initiation codon, and a multicloning site, which places the heterologous gene in fusion with either the ␤-lactamase signal sequence or the whole ␤-lactamaseencoding gene in pLA71 or pLA73, respectively. Construction of the S1PT expression vector. To construct pNL71S1 and pNL73S1, a ⬃700-bp fragment containing the genetically detoxified S1PT gene was amplified by PCR from pUC-9K/129G, using primers 5⬘-TAGTAGTCTAG AGCGGCCGCCTAGAACGAATACGCGATGCT-3⬘ containing XbaI (italic) and NotI (underlined) restriction sites and 5⬘-TAGTAGTCTAGAGGTACCGG ACGACGATCCTCCCGCCACC-3⬘ containing XbaI (italic) and KpnI (underlined) restriction sites (Bio-Synthesis, Inc., Lewisville, Tex.). The PCR fragment was then digested with XbaI and cloned into XbaI-restricted pUC18. The 720-bp KpnI/NotI fragment containing the S1 gene was then inserted into the pLA71 and pLA73 shuttle vector previously digested with KpnI and NotI. The resulting plasmids, pLN71S1 and pLN73S1 (Fig. 1), were electrotransfected into BCG, and transformants were selected by their resistance to kanamycin.

INFECT. IMMUN.

FIG. 1. Schematic representation of the promoter and antigen regions of the shuttle vectors pNL71S1 and pNL73S1. Both vectors contain the E. coli and mycobacterial origins of replication and the kanamycin resistance gene. T, omega terminator; ssBlam, ␤-lactamase initiation codon and signal sequence. S1PT is placed in fusion with ssBlam in pNL71S1 and with Blam, the whole ␤-lactamase gene, in pNL73S1.

Western blotting. One or more kanamycin-resistant BCG clones were grown in 50-ml Middlebrook liquid cultures supplemented with kanamycin (20 ␮g/ml). The cells of 25-ml cultures were harvested at mid-log phase by centrifugation, washed once with 5 ml of Tris-EDTA, resuspended in 0.5 ml of Tris-EDTA, and disrupted on ice for 3 min with an Ultrasonic Processor GE 100 at half-maximum constant output. Protein concentration in the culture lysates was determined by the Bio-Rad protein assay, using bovine serum albumin (BSA) as a standard. Approximately 50-␮g aliquots of protein extracts were separated by sodium dodecyl sulfate-polyacrylamide gel electrophoresis (SDS-PAGE) (10% gel). The proteins were then electrotransferred onto a nitrocellulose membrane (Protran; Schleicher & Schuell), and the membrane was saturated with 5% nonfat dry milk in PBS containing 0.1% (vol/vol) Tween 20 (Sigma, St. Louis, Mo.) (PBS-T). The presence of S1PT was detected using a mouse polyclonal antiserum (1:1,000) raised against PT detoxified by formaldehyde treatment (dPT; kindly provided by H. and Y. Sato, National Institute of Health, Tokyo, Japan); the immunoblots were developed with goat anti-mouse peroxidase-conjugated antibodies (1:1,000; Sigma) and visualized with an Amersham ECL kit. Localization of heterologous proteins in rBCG. Clones of rBCG-S1PT expressing the heterologous protein were grown in 30-ml cultures of Ungar medium supplemented with kanamycin (20 ␮g/ml). The cells were harvested at mid-log phase by centrifugation. The proteins from the culture supernatants were concentrated by ultrafiltration (Centricon 3; Amicon Corp., Danvers, Mass.). The cell pellet was resuspended in PBS, adjusting cell density to equivalent values, and sonicated for 6 min as described above. Membranes were solubilized by the addition of 2% (vol/vol) Triton X-114. Insoluble material (cell wall-enriched fraction) was separated by centrifugation at 27,000 ⫻ g, and the supernatant was submitted to detergent phase partitioning, separating the membrane and cytosol fractions, as described elsewhere (31). Samples from each fraction were submitted to SDS-PAGE and Western blotting as described above. ELISA. Serum antibody responses to S1PT in pooled sera of immunized animals were quantitated by enzyme-linked immunosorbent assay (ELISA). Briefly, Polysorp 96-well plates (Nunc International, Rochester, N.Y.) were coated with dPT (100 ␮l; 2 ␮g/ml in bicarbonate-carbonate buffer, pH 9.6; 4°C overnight), washed three times with PBS-T, and then blocked with 5% nonfat dry milk in PBS. The plates were then incubated with serial dilutions of mouse serum in PBS–1% BSA at 37°C for 1 h. The plates were washed as described above and incubated with peroxidase-conjugated goat anti-mouse immunoglobulin G (Sigma) in PBS–1% BSA at 37°C for 1 h. Following washing, antibodies were visualized by adding OPD substrate (0.04% o-phenylenediamine [OPD] in citrate phosphate buffer [pH 5] containing 0.01% H2O2). After color development (10 min), the reaction was interrupted with 8 M H2SO4, and the A492 was determined. Absorbance values were plotted against dilutions. Preparation of spleen cells. Spleens were removed from two Swiss mice 2 weeks after immunization with rBCG-pNL71S1 or the saline and BCG controls, and a single-cell suspension was prepared in RPMI 1640 medium (Sigma) supplemented with 2 mM L-glutamine (Merck, Darmstadt, Germany), 50 ␮g of gentamicin sulfate (Schering-Plough, Rio de Janeiro, Rio de Janeiro, Brazil) per ml, and 10 mM HEPES buffer (Sigma). The cells were washed once and treated with distilled water to remove erythrocytes. The cells were washed twice and resuspended in complete medium: RPMI 1640, as above, plus 10% fetal calf serum (FCS) (Cultilab; Campinas, Sa˜o Paulo, Brazil) and 0.05 mM 2-mercaptoethanol (Pharmacia LKB Biotechnology AB, Uppsala, Sweden). Cells (2 ⫻ 106/ml) were cultured in 24-well tissue culture plates (Corning Glass Works, Corning, N.Y.) in a volume of 1 ml per well, with dPT (1 ␮g/ml) as the antigenspecific stimulation and concanavalin A (5 ␮g/ml; Sigma) as a positive control for cell reactivity. Control cells were incubated only in complete medium, without antigen. Cultures were incubated for 3 days in a humidified 5% CO2 incubator at 37°C. The culture supernatants were harvested at 24, 48, and 72 h, in order to

VOL. 68, 2000

PROTECTION INDUCED BY rBCG-S1 PERTUSSIS TOXIN

FIG. 2. Expression of S1PT in rBCG. Cell extracts of BCG or rBCG (50 mg) were analyzed by Western blotting using an anti-PT polyclonal antibody. Lane 1, BCG; lane 2, rBCG-pLA71; lanes 3 to 5, rBCG-pNL71S1; lane 6, rBCGpLN73S1; lane 7, purified PT from wild-type B. pertussis.

determine the optimum time for lymphokine secretion, and stored at ⫺20°C for further quantitation of gamma interferon (IFN-␥) and interleukin-4 (IL-4). Lymphokine assays. IFN-␥ and IL-4 levels in the supernatants of stimulated cells were quantitated by ELISA as described elsewhere (7). Purified rat antimouse IFN-␥ (2 ␮g/ml) and anti-mouse IL-4 (1 ␮g/ml) monoclonal antibodies (PharMingen, San Diego, Calif.) were used as capture antibodies, coated overnight at 4°C in flat-bottom 96-well microtiter plates (Immunoplates-Maxisorp; Nunc International) in a volume of 50 ␮l of 0.1 M NaHCO3, pH 8.2. Washes between each step (three to six times) were performed with PBS containing 0.05% Tween 20 (Sigma). The plates were blocked with PBS containing 10% FCS overnight at 4°C. Lymphocyte culture supernatants were added to the plates without dilution in quadruplicate, and the plates were incubated for 3 h at room temperature. Recombinant mouse cytokines IFN-␥ and IL-4 (PharMingen) were used for the generation of the standard curve. Biotinylated rat anti-mouse IFN-␥ (1 ␮g/ml) and anti-mouse IL-4 (0.5 ␮g/ml) monoclonal antibodies (PharMingen) were added in a volume of 50 ␮l of PBS containing 0.05% Tween 20 (Sigma) per well and incubated for 1 h at room temperature. Bound antibodies were detected by use of ExtrAvidin-horseradish peroxidase conjugates (Sigma). A dye-substrate buffer containing 0.2% (wt/vol) OPD and 0.015% (vol/vol) H2O2 diluted in 24.3% (vol/vol) 0.1 M citric acid–25.7% (vol/vol) 0.2 M Na2HPO4 was added and allowed to react for 15 to 30 min. Color development was interrupted by addition of 4.5 M H2SO4, and A492 was determined. Sample concentrations from standard curves were obtained by nonlinear regression analysis (GraphPad Prism, version 2.0). Proliferation assay. Spleen cells were harvested from 72-h cultures and prepared in RPMI 1640 supplemented with 2% FCS. The proliferative responses were determined on the basis of 3-(4,5-dimethylthiazol-2-yl)-2,5-diphenyltetrazolium bromide (MTT; Sigma) conversion to formazan as described elsewhere (11), with minor modifications. In brief, MTT solution (20 ␮l, 5 mg/ml) was added to 100 ␮l of medium and incubated for 3 h at 37°C. A solution of PBS containing 10% SDS and 0.01 M HCl (100 ␮l) was added, and the mixture was incubated for another 18 h. Color formation was measured by the A595. One proliferative unit is equivalent to one optical density unit at 595 nm, and the value obtained for saline-inoculated mice was subtracted. Statistical analysis was performed by the Student-Newman-Keuls multiple-comparisons test. B. pertussis i.c. challenge. Immunized mice were inoculated i.c. with 30 ␮l of a bacterial suspension of B. pertussis strain 18323 (18,500 or 30,000 CFU, depending on weight), and survival was monitored twice daily for 17 days. Mice not surviving the first 3 days were considered to have been improperly inoculated. The level of protection afforded was expressed as the percentage of surviving mice.

RESULTS Expression and localization of S1PT in rBCG. We have expressed the nontoxic S1 subunit of PT-9K/129G in BCG, under control of the upregulated M. fortuitum pBlaF*, in fusion with either the ␤-lactamase signal sequence (using pLA71) or the whole ␤-lactamase gene (using pLA73), leading to rBCG-pNL71S1 or rBCG-pNL73S1, respectively (Fig. 1). Mycobacterial cell extracts from transformed BCG clones were submitted to immunoblot analysis using a polyclonal anti-PT antibody. As shown in Fig. 2, three clones of rBCG transformed with pNL71-S1 expressed the ⬃30-kDa fusion protein comprising the ␤-lactamase signal sequence and S1PT. The

4879

free S1 subunit can be seen as the slower-migrating band with 26.2 kDa from purified PT. An rBCG clone transformed with pNL73S1 expressed the 57-kDa ␤-lactamase–S1PT fusion protein at significantly higher levels, although even in this case it was not possible to detect the heterologous protein in Coomassie blue-stained SDS-polyacrylamide gels (comigration with major mycobacterial proteins may have hindered detection). The fusion protein produced by pNL73S1 showed few lower-molecular-weight bands, probably due to some degree of fusion protein degradation. Neither BCG nor BCG transformed with pLA73 showed any immunoreactive bands. Fractionation by Triton X-114 detergent phase partitioning showed that the heterologous proteins produced from both rBCGpNL71S1 and rBCG-pNL73S1 were localized to the cell wall (results not shown). Very small amounts of extracellular S1 fusion proteins were detected in the culture supernatant, and none was found in the membrane fraction or cytosol. In vivo stability of rBCG-S1PT. Swiss mice were inoculated i.p. with 106 CFU of rBCG-pNL71S1 per animal. One and two months later, animals were sacrificed, spleens were separated and homogenized, and spleen extracts were plated in Middlebrook 7H10 in the presence or absence of kanamycin (20 ␮g/ml). Stability of the expression vector was determined as a ratio of kanamycin-resistant colonies to colonies obtained in the absence of antibiotics. At 1 month, the ratio had decreased to 0.86, and at 2 months it was still 0.85. The total number of colonies recovered from the spleens of inoculated animals at 8 weeks was approximately 530 for both BCG and rBCGpNL71S1. Humoral responses to rBCG-S1PT. Groups of five male BALB/c mice were immunized i.p. with 106 CFU of rBCGpNL71S1 or rBCG-pNL73S1. Control mice were immunized with saline, BCG, or DPT. A booster under the same conditions was administered at 10 weeks. Sera was collected every 4 weeks after immunization, pooled, and tested by ELISA for the induction of antibodies against dPT. As shown in Fig. 3, mice immunized with rBCG-pNL71S1 showed a twofold increase in anti-PT antibodies in relation to saline or BCG controls at 2 months from the initial vaccination. Antibody levels then decreased steadily, reaching levels comparable to the control level at 5 months. Neither rBCG-pNL73S1 nor DPT induced a major increase in anti-PT antibodies. However, in a short-term experiment in which the humoral response was monitored at weekly intervals, a twofold increase in anti-PT

FIG. 3. Antibody response induced by rBCG-S1PT. BALB/c mice were immunized i.p. with rBCG-S1 strains rBCG-pNL71S1 and rBCG-pNL73S1 (106 CFU/0.5 ml) or the positive (DPT) and negative (saline [Sal] or BCG) controls, receiving a booster dose under the same conditions at 10 weeks as described in Materials and Methods. Sera were collected at the indicated times, pooled, and analyzed for anti-PT antibodies by ELISA. A492 of sera diluted 1:20 is shown.

4880

NASCIMENTO ET AL.

FIG. 4. PT-specific IL-4 and IFN-␥ production in spleen cells derived from BCG- and rBCG-pNL71S1-immunized mice. Cytokine content was estimated as described in Materials and Methods after stimulation with dPT. The error bars indicate standard deviations. Sal, saline.

antibodies was observed at 1 week in rBCG-73S1PT-immunized animals, which was decreased by 2 weeks (results not shown). Also in this experiment, again DPT showed no humoral response under the same conditions (0.8 of the human dose), but when we used a lower dose (0.12 of the human dose), an antibody response comparable to that obtained by rBCG-73S1PT was observed (not shown). At 6 months, these immunized animals were challenged i.c. with live B. pertussis. The only animals surviving at 13 days postchallenge were two of five in the group vaccinated with rBCG-pNL71S1, and one of five in the group receiving rBCG-pNL73S1. The last surviving animal immunized with DPT died on the last day. This experiment demonstrated that the i.c. challenge is not appropriate to evaluate protection in older mice and indicated that the rBCG-S1PT vaccines may have induced some level of protection. Since rBCG-pNL71S1 also induced higher antibody levels, we investigated the induction of a cellular response by this strain. Lymphokine production induced by rBCG-S1PT. Swiss mice were inoculated with rBCG-pNL71S1 or the saline and BCG controls. Two weeks later, spleen cells were isolated for quantification of IFN-␥ and IL-4 production following stimulation with dPT. The in vitro lymphokine secretion profiles of dPTstimulated spleen cells revealed marked differences among the groups (Fig. 4). Both IFN-␥ and IL-4 levels peaked at 48 h in culture (not shown). Figure 4 shows that splenocytes from rBCG-S1PT-immunized mice induced the secretion of high levels of IFN-␥ when stimulated with dPT. Cells derived from BCG-immunized mice also showed an increase in IFN-␥ production, although to a lower degree. IL-4 secretion was also increased in the splenocytes from BCG-immunized mice, and the expression of S1PT decreased IL-4 secretion to control levels. On the whole, IFN-␥ levels were higher than IL-4 levels. Proliferative response against PT. Spleen lymphocytes isolated from rBCG-pNL71S1-immunized mice showed 50% proliferation in response to stimulation with dPT compared to saline controls (P ⬍ 0.001) or 25% in relation to BCG-immunized controls (P ⬍ 0.05), as shown in Fig. 5. The proliferative response correlated with the cellular response, and BCG alone also induced some degree of proliferation in response to the stimulus with dPT. Protection against an i.c. challenge with live B. pertussis. Groups of five male Swiss mice were immunized i.p. with one of the following vaccine preparations: saline, BCG, rBCGpNL71S1, rBCG-pNL73S1, and DPT. At day 14, all groups were challenged i.c. with a previously determined mean lethal dose of live B. pertussis under the same conditions as used to

INFECT. IMMUN.

FIG. 5. Proliferation of spleen cells derived from BCG- and rBCG-pNL71S1immunized mice upon PT stimulation. Proliferation 72 h after stimulation with detoxified PT was measured as MTT conversion to formazan as described in Materials and Methods. The values obtained for saline (0.88 ⫾ 0.10) were subtracted from those obtained by BCG and rBCG-pNL71S1. The error bars indicate standard deviations, which were lower than 10% of the obtained values. Student’s test: ⴱ, P ⬍ 0.01 compared with BCG; ⴱⴱ, P ⬍ 0.001 compared with saline.

certify the potency of commercial whole-cell pertussis vaccines. As shown in Table 1, rBCG-pNL73S1, expressing S1PT in fusion with the whole ␤-lactamase protein, induced complete protection of mice against challenge, comparable to that obtained with the commercial DPT vaccine. Animals immunized with rBCG-pNL71S1, expressing S1PT in fusion with the ␤-lactamase signal sequence, also induced a high level of protection. BCG-immunized mice showed a slightly higher survival than the saline control group or a delay in the time of death. Previous experiments using saline, BCG, and rBCG-pLA71 showed that BCG and the vector strain were equivalent and that occasionally they induced low-level protection, consistent with the immunostimulatory properties of BCG (not shown). To confirm these results, larger groups of animals (10 male Swiss mice) were immunized with 106 CFU of rBCG-pNL71S1 or the positive and negative controls, DPT and saline. At day 14, mice were submitted to an i.c. challenge with live B. pertussis. Survival of immunized animals was monitored for 17 days. As shown in Fig. 6, immunization with rBCG-pNL71S1 induced protection of 78%, compared with 90% in DPT-immunized animals. Although some variability in the degree of protection can be observed in the different challenge experiments, on the whole, these results demonstrate that BCG expressing the S1 subunit of PT in fusion with different fragments of ␤-lactamase induces a high level of protection against an i.c. challenge with live B. pertussis. DISCUSSION Several attempts have been made to develop improved vaccines against B. pertussis. Since PT is considered the major TABLE 1. Challenge i.c. of rBCG-S1-immunized mice with live B. pertussisa Group

Days of death after challenge

Saline...............................................................7, 8, 8, 8, ⬎13 BCG ................................................................6, 8, 10, ⬎13, ⬎13 rBCG-pNL71S1 .............................................8, ⬎13, ⬎13, ⬎13, ⬎13 rBCG-pNL73S1 .............................................⬎13, ⬎13, ⬎13, ⬎13, ⬎13 DPT.................................................................⬎13, ⬎13, ⬎13, ⬎13, ⬎13 a Groups of five male Swiss mice, previously vaccinated (106 CFU/0.5 ml) with the BCG or rBCG strain expressing S1PT or with the saline and DPT controls were challenged i.c. with 18,500 CFU of live B. pertussis in 30 ␮l of saline, and survival was monitored for 13 days.

VOL. 68, 2000

PROTECTION INDUCED BY rBCG-S1 PERTUSSIS TOXIN

FIG. 6. Protection of mice immunized with rBCG-S1PT against B. pertussis i.c. challenge. Groups of 10 Swiss mice immunized i.p. 2 weeks before with rBCG-pNL71S1 (106 CFU/0.5 ml; squares), the negative control receiving 500 ␮l of saline (triangles), and the positive control receiving 400 ␮l of DPT (circles) were challenged i.c. with 1 mean lethal dose of live B. pertussis. Survival was monitored over 17 days.

immunogen of B. pertussis, most systems tested are based on PT, genetically detoxified or not (12, 28, 38). Following cloning and sequencing of the five subunits of PT, it was genetically detoxified by site-directed mutagenesis of the active subunit S1, generating PT-9K/129G. Mutant B. pertussis expressing this inactive PT showed immunogenicity equivalent to the wholecell chemically detoxified vaccine (33), and purified PT-9K/ 129G was comparable to the acellular PT vaccine (27). Attempts to express the five subunits of PT in E. coli required fusion of the subunits to other proteins (29). A recombinant Salmonella enterica serovar Typhimurium aroA strain expressing the five subunits of PT failed to protect mice from a virulent challenge, probably due to incomplete processing of the subunits (8). Of the five subunits composing the PT holotoxin, S1 has been characterized as the most immunogenic moiety (10), and passive immunization with an anti-S1PT monoclonal antibody protected mice against a virulent challenge (39). The S1 subunit has been expressed in fusion or unfused and has been purified from recombinant E. coli or Bacillus subtilis, maintaining its activity and immunochemical properties (3, 23, 30, 37). Fusion of genetically detoxified S1PT to tetanus toxin fragment C (TTFc) has been shown to increase expression of the fusion protein in E. coli (6). With the growing evidences on the advantages of recombinant vaccines based on live vectors, the S1 subunit has been expressed alone or in fusion with TTFc in different vaccine strains of Salmonella, invasive E. coli, Streptococcus gordonii, and BCG, inducing protective antibodies or a cellular response against PT (2, 4, 21). In this study we have constructed rBCG strains expressing the detoxified S1 subunit of PT under control of the upregulated pBlaF* in fusion either with the ␤-lactamase exportation signal (BCG-pNL71S1) or with the whole ␤-lactamase protein (BCG-pNL73S1). Expression levels of the S1 fusion proteins in rBCG-pNL73S1 were considerably higher than with rBCGpNL71S1 (Fig. 2), confirming the importance of protein fusion in the expression levels of S1PT. On the other hand, fusion with smaller fragments of ␤-lactamase would be more convenient for vaccine purposes. The fusion proteins were relatively stable, showing few degradation products in rBCG-pNL73S1. Both strains directed the fusion proteins to the cell wall, with very small amounts in the extracellular media, indicating that exportation was initiated but probably blocked by the thick cell wall components. Expression of S1PT in fusion with TTFc has previously been obtained in rBCG, using the 85A antigen promoter and signal sequence or the hsp60 promoter, the latter of

4881

which induced a higher level of expression (2). Fusion to the 85A signal sequence had not attained exportation of the heterologous protein, which was attributed to its large size. Although the ␤-lactamase signal sequence has been shown to export other recombinant proteins expressed in BCG, and the fusion protein in BCG-pNL71S1 has a reduced size, complete exportation was not achieved, indicating that the size of the expressed protein is not the only factor hindering its translocation through the mycobacterial cell wall. Besides the level of antigen expression and localization, another factor influencing the induction of an efficient immune response in live vaccine vectors is the stability of the expression system. Integrative vectors are considered to display lower expression but higher stability. On the other hand, plasmids are considered to provide higher expression levels but to be less stable in vivo. Although many mycobacterial expression systems comprising different antigens have been investigated, few have been characterized in relation to their in vivo plasmid stability. We have inoculated mice with rBCG-pNL71S1 and monitored mycobacterial recovery and kanamycin resistance for up to 2 months. At 1 month, the number of kanamycinresistant colonies was 86% of that recovered in the absence of antibiotics. At 2 months, 85% of the BCG colonies recovered from the spleen were still resistant to kanamycin, indicating that this expression vector was relatively stable. The total number of rBCG clones recovered from the spleen was comparable to that obtained from nonrecombinant BCG-inoculated mice, showing that the transfected expression vector did not alter BCG persistence in mice. BALB/c mice immunized with the rBCG-S1PT strains produced low levels of serum anti-PT antibodies, as well as the whole-cell DPT vaccine, when followed up to 6 months (Fig. 3). At 15 days from immunization with rBCG-S1PT strains or with DPT, Swiss mice showed no anti-PT antibodies (not shown). These experiments are in agreement with previous results suggesting that the humoral response against PT may not be the most important component for induction of protection (32), since the conventional DPT whole-cell vaccine is considered very efficient. On the other hand, increasing evidence suggests the importance of the induction of a cellular response against PT for protection against B. pertussis (26, 32). Previous studies have shown that rBCG expressing the S1TTFc fusion protein under control of the hsp60 promoter induces a weak but significant cellular response against PT, as determined by the antigen-specific secretion of IL-2 (38). In this study, spleen cells obtained from mice immunized 2 weeks before with rBCG-pNL71S1 showed a significant increase in production of IFN-␥ and in the proliferative response upon stimulation with detoxified PT compared to the saline and BCG controls (Fig. 4 and 5). On the whole, IFN-␥ levels were higher than IL-4 levels, suggesting induction of a Th1-dominant response by these rBCG-S1PT strains. This cytokine pattern correlates with that observed in patients convalescing from whooping cough (32), and B. pertussis infection is known to provide a more efficient protection than vaccination. Mice immunized with rBCG-S1PT strains displayed highlevel protection against an i.c. challenge with live B. pertussis (Table 1; Fig. 6), which correlated with the induction of a PT-specific cellular immune response (IFN-␥ production) and proliferation (Fig. 4 and 5). These results reinforce the importance of the induction of cell-mediated immunity in the protection against B. pertussis infection. Our results show that the pBlaF* and ␤-lactamase signal sequences in rBCG can drive adequate expression levels and presentation of heterologous antigens to the immune system. A more effective vaccine against B. pertussis should also include antigens involved in

4882

NASCIMENTO ET AL.

colonization, and we are investigating the expression of complementary proteins in rBCG. DPaT vaccines have been shown to be efficient and less reactogenic than whole-cell DPT vaccines, but the high costs of processing render them expensive, which will hinder widespread use in developing countries. BCG is used as a vaccine against tuberculosis in most developing countries, in which it is an important control mechanism. Safer and more efficient mycobacterial vaccines, addressing the problem of use in immunocompromised individuals, may be developed in the near future (15, 17); some of these may be used as carriers for heterologous antigens in much the same way as BCG. Combined rBCG-pertussis vaccines administered once, separate from the DT vaccination, would be a significant improvement over the currently used BCG-DPT and BCG-DaPT schedules. Even better would be a combined rBCG-DPT vaccine; we are currently working on the expression of tetanus and diphtheria antigens in rBCG. ACKNOWLEDGMENTS This work was supported by Fundac¸˜ao de Amparo `a Pesquisa do Estado de Sa˜o Paulo (FAPESP) grant 96/11.539-0, CNPq grant 551102/97-9, and Fundac¸˜ao Butantan. We thank M. G. Trevelin, S. R. Silva, and S. V. Oliveira for technical assistance and F. A. M. Oliveira for secretarial assistance. REFERENCES 1. Abdelhak, S., H. Louzir, J. Timm, L. Blel, Z. Benlasfar, M. Lagranderie, M. Gheorghiu, K. Dellagi, and B. Gicquel. 1995. Recombinant BCG expressing the leishmania surface antigen Gp63 induces protective immunity against Leishmania major infection in BALB/c mice. Microbiology 141:1585–1592. 2. Abomoelak, B., K. Huygen, L. Kremer, M. Turneer, and C. Locht. 1999. Humoral and cellular immune responses in mice immunized with recombinant Mycobacterium bovis bacillus Calmette-Gue´rin producing a pertussis toxin-tetanus toxin hybrid protein. Infect. Immun. 67:5100–5105. 3. Barbieri, J. T., R. Rappuoli, and R. J. Collier. 1987. Expression of the S1 catalytic subunit of pertussis toxin in Escherichia coli. Infect. Immun. 55: 1321–1323. 4. Barry, E. M., O. Gomez-Duarte, S. Chatfield, R. Rappuoli, M. Pizza, G. Losonsky, J. Galen, and M. M. Levine. 1996. Expression and immunogenicity of pertussis toxin S1 subunit-tetanus toxin fragment C fusions in Salmonella typhi vaccine strain CVD 908. Infect. Immun. 64:4172–4181. 5. Blumberg, D. A., K. Lewis, C. M. Mink, P. D. Christenson, P. Chatifield, and J. D. Cherry. 1993. Severe reactions associated with diphtheria-tetanuspertussis vaccine: detailed study of children with seizures, hypotonic-hyporesponsive episodes, high fevers, and persistent crying. Pediatrics 91:1158– 1165. 6. Boucher, P., H. Sato, Y. Sato, and C. Locht. 1994. Neutralizing antibodies and immunoprotection against pertussis and tetanus obtained by use of a recombinant pertussis toxin-tetanus toxin fusion protein. Infect. Immun. 62:449–456. 7. Cainelli Gebara, V. C. B., V. L. Petricevich, I. Raw, and W. D. Silva. 1995. Effect of saponin from Quillaja saponaria (molina) on antibody, tumor necrosis factor and interferon-␥ production. Biotechnol. Appl. Biochem. 21: 31–37. 8. Dalla Pozza, T., H. Yan, D. Meek, C. A. Guzman, and M. J. Walker. 1998. Construction and characterization of Salmonella typhimurium aroA simultaneously expressing the five pertussis toxin subunits. Vaccine 16:522–529. 9. Dellagostin, O. A., G. Esposito, L. J. Eales, J. W. Dale, and J. McFadden. 1995. Activity of mycobacterial promoters during intracellular and extracellular growth. Microbiology 141:1785–1792. 10. De Magistris, M. T., M. Romano, A. Bartoloni, R. Rappuoli, and A. Tagliabue. 1989. Human T cell clones define S1 subunit as the most immunogenic moiety of pertussis toxin and determine its epitope map. J. Exp. Med. 169:1519–1532. 11. Denizot, F., and R. Lang. 1986. Rapid colorimetric assay for cell growth and survival. Modifications to the tetrazolium dye procedure giving improved sensitivity and reliability. J. Immunol. Methods 89:271–277. 12. Edwards, K. M., B. D. Meade, M. D. Decker, G. F. Reed, M. B. Rennels, M. C. Steinhoff, E. L. Anderson, J. A. Englund, M. E. Pichichero, and M. A. Deloria. 1995. Comparison of 13 acellular pertussis vaccines: overview and serologic response. Pediatrics 96(3 Pt.2):548–557. 13. Fennelly, G. J., W. R. Jacobs, Jr., and B. R. Bloom. 1997. The BCG as a recombinant vaccine vector, p. 363–385. In M. M. Levine, G. C. Woodrow, J. B. Kaper, and G. S. Cobon (ed.), New generation vaccines, 2nd ed. Marcel Dekker, Inc., New York, N.Y.

INFECT. IMMUN. 14. Gicquel, B. 1995. BCG as a vector for the construction of multivalent recombinant vaccines. Biologicals 23:113–118. 15. Greco, D., S. Salmaso, P. Mastrantonio, M. Giuliano, A. E. Tozzi, A. Anemona, M. L. C. D. Atti, A. Giammanco, P. Panei, W. C. Blackwelder, D. L. Klein, S. G. F. Wassilak, and the Progetto Pertosse Working Group. 1996. A controlled trial of two acellular vaccines and one whole-cell vaccine against pertussis. N. Engl. J. Med. 334:341–348. 16. Guleria, I., R. Teitelbaum, R. A. McAdam, G. Kalpana, W. R. Jacobs, Jr., and B. R. Bloom. 1996. Auxotrophic vaccines for tuberculosis. Nat. Med. 2:334–337. 17. Hemert, P. F. 1974. Vaccine production as a unit process, p. 227–233. In D. J. D. Hockenhull (ed.), Progress in industrial microbiology. Churchill Livingston, Edinburg, United Kingdom. 18. Jackson, M., S. W. Phalen, M. Lagranderie, D. Ensergueix, P. Chavarot, G. Marchal, D. N. McMurray, B. Gicquel, and C. Guilhot. 1999. Persistence and protective efficacy of a Mycobacterium tuberculosis auxotroph vaccine. Infect. Immun. 67:2867–2873. 19. Kremer, L., G. Riveau, A. Baulard, A. Capron, and C. Locht. 1996. Neutralizing antibody responses elicited in mice immunized with recombinant Bacillus Calmette-Gue´rin producing the Schistosoma mansoni glutatione Stransferase. J. Immunol. 156:4309–4317. 20. Langermann, S., S. R. Palaszynski, J. E. Burlein, S. Koenig, M. S. Hanson, D. E. Briles, and C. K. Stover. 1994. Protective humoral response against pneumococcal infection in mice elicited by recombinant Bacille CalmetteGue´rin vaccines expressing pneumococcal surface protein A. J. Exp. Med. 180:2277–2286. 21. Lee, S. F., R. J. March, S. A. Halperin, G. Faulkner, and L. Gao. 1999. Surface expression of a protective recombinant pertussis toxin S1 subunit fragment in Streptococcus gordonii. Infect. Immun. 67:1511–1516. 22. Lim, E. M., J. Rauzier, J. Timm, G. Torrea, A. Murray, B. Gicquel, and D. Portnoi. 1995. Identification of Mycobacterium tuberculosis DNA sequences encoding exported proteins by using phoA gene fusions. J. Bacteriol. 177: 59–65. 23. Locht, C., W. Cieplak, K. S. Marchitto, H. Sato, and J. M. Keith. 1987. Activities of complete and truncated forms of pertussis toxin subunits S1 and S2 synthesized by Escherichia coli. Infect. Immun. 55:2546–2553. 24. Manclarck, C. R., and D. L. Burns. 1985. Prospects for a new acellular pertussis vaccine. Ann. Inst. Pasteur Microbiol. 136B:323–329. 25. Matsumoto, S., Y. Hideharu, H. Kanbara, and T. Yamada. 1998. Recombinant Mycobacterium bovis Bacillus Calmette-Gue´rin secreting merozoite surface protein 1 (MSP1) induces protection against rodent malaria parasite infection depending on MSP-1-stimulated interferon ␭ and parasite-specific antibodies. J. Exp. Med. 188:845–854. 26. Mills, K. H. G., A. Barnard, J. Watkins, and K. Redhead. 1993. Cellmediated immunity to Bordetella pertussis: role of Th1 cells in bacterial clearance in a murine respiratory infection model. Infect. Immun. 61:399– 410. 27. Nencioni, L., M. Pizza, M. Bugnoli, T. Magistris, A. Tommaso, F. Giovannoni, R. Manetti, I. Marsili, G. Matteucci, D. Nucci, R. Olivieri, P. Pileri, R. Presentini, L. Villa, J. G. Kreeftenberg, S. Silvestri, A. Tagliabue, and R. Rappuoli. 1990. Characterization of genetically inactivated pertussis toxin mutants: candidates for a new vaccine against whooping cough. Infect. Immun. 58:1308–1315. 28. Nencioni, L., G. Volpini, S. Peppoloni, M. Bugnoli, T. Magistris, I. Marsili, and R. Rappuoli. 1991. Properties of pertussis toxin mutant PT-9K/129G after formaldehyde treatment. Infect. Immun. 59:625–630. 29. Nicosia, A., A. Bartoloni, M. Perugini, and R. Rappuoli. 1987. Expression and immunological properties of the five subunits of pertussis toxin. Infect. Immun. 55:963–967. 30. Olander, R. M., A. Muotiala, J. P. Himanen, M. Karvonen, U. Airaksinen, and K. Runeberg-Nyman. 1991. Immunogenicity and protective efficacy of pertussis toxin subunit S1 produced by Bacillus subtilis. Microb. Pathog. 10:159–164. 31. Parish, T., and P. R. Wheeler. 1998. Preparation of cell-free extracts from mycobacteria. Methods Mol. Biol. 101:77–89. 32. Peppoloni, S., L. Nencioni, A. Di Tommaso, A. Tagliabue, P. Parronchi, S. Romagnani, R. Rappuoli, and M. T. De Magistris. 1991. Lymphokine secretion and cytotoxic activity of human CD4⫹ T-cell clones against Bordetella pertussis. Infect. Immun. 59:3768–3773. 33. Pizza, M., A. Covacci, A. Bartoloni, M. Perugini, L. Nencioni, M. T. De Magistris, L. Villa, D. Nucci, R. Manetti, M. Bugnoli, F. Giovannoni, R. Olivieri, J. T. Barbieri, H. Sato, and R. Rappuoli. 1989. Mutants of pertussis toxin suitable for vaccine development. Science 246:497–500. 34. Robbins, J. B., M. Pittman, B. Trollfors, T. A. Lagergard, J. Taranger, and R. Schneerson. 1993. Primum non nocere: a pharmacologically inert pertussis toxoid alone should be the next pertussis vaccine. Pediatr. Infect. Dis. 12: 795–807. 35. Robinson, A., L. I. Irons, and L. A. E. Ashworth. 1985. Pertussis vaccine: present status and future prospects. Vaccine 3:11–22. 36. Romanus, V., R. Jonsell, and S. O. Bergquist. 1987. Pertussis in Sweden after the cessation of general immunization in 1979. Pediatr. Infect. Dis. J. 6:364– 371.

VOL. 68, 2000

PROTECTION INDUCED BY rBCG-S1 PERTUSSIS TOXIN

37. Runeberg-Nyman, K., O. Engstrom, S. Lofdahl, S. Ylostalo, and M. Sarvas. 1987. Expression and secretion of pertussis toxin subunits S1 in Bacillus subtilis. Microb. Pathog. 3:461–468. 38. Sato, Y., M. Kimura, and H. Fukumi. 1984. Development of a pertussis component vaccine in Japan. Lancet 21:122–126. 39. Sato, H., and Y. Sato. 1990. Protective activities in mice of monoclonal antibodies against pertussis toxin. Infect. Immun. 58:3369–3374. 40. Stein, P. E., A. Boodhoo, G. D. Armstrong, S. A. Cockle, M. H. Klein, and R. J. Read. 1994. The crystal structure of pertussis toxin. Structure 2:45–57. 41. Stover, C. K., G. P. Bansal, M. S. Hanson, J. E. Burlein, S. R. Palaszynski, J. F. Young, S. Koenig, D. B. Young, A. Sadziene, and A. G. Barbour. 1993. Protective immunity elicited by recombinant Bacille Calmette-Gue´rin (BCG) expressing outer surface protein A (OspA) lipoprotein: a candidate Lyme disease vaccine. J. Exp. Med. 178:197–209. 42. Stover, C. K., V. de la Cruz, T. R. Fuerst, J. E. Burlein, L. A. Benson, L. T. Bennett, G. P. Bansal, J. F. Young, M. H. Lee, G. F. Hatfull, et al. 1991. New use of BCG for recombinant vaccines. Nature 351:456–460. 43. Timm, J., M. G. Perilli, C. Duez, J. Trias, G. Orefici, L. Fattorini, G. Amicosante, A. Oratore, B. Joris, J. M. Frere, A. P. Pusgley, and B. Gicquel.

Editor: D. L. Burns

44.

45. 46.

47.

4883

1994. Transcription and expression analysis, using lacZ and phoA gene fusions, of Mycobacterium fortuitum beta-lactamase genes cloned from a natural isolate and a high-level beta-lactamase producer. Mol. Microbiol. 12:491–504. Wada, N., N. Ohara, M. Kameoka, Y. Nishino, S. Matsumoto, T. Nishiyama, M. Naito, H. Yukitake, Y. Okada, K. Ikuta, and T. Yamada. 1996. Longlasting immune response induced by recombinant bacillus Calmette-Guerin (BCG) secretion system. Scand. J. Immunol. 432:202–209. Wardlaw, A. C., and R. Parton. 1983. Bordetella pertussis toxin. Pharmacol. Ther. 19:1–53. Winter, N., M. Lagranderie, S. Gangloff, C. Leclerc, M. Gheorghiu, and B. Gicquel. 1995. Recombinant BCG strains expressing the SIVmac251nef gene induce proliferative and CTL responses against nef synthetic peptides in mice. Vaccine 13:471–478. Winter, N., M. Lagranderie, J. Rauzier, J. Timm, C. Leclerc, B. Guy, M. P. Kieny, M. Gheorghiu, and B. Gicquel. 1991. Expression of heterologous genes in Mycobacterium bovis BCG: induction of a cellular response against HIV-1 Nef protein. Gene 109:47–54.