We have your solution ... and the best part is it's conveniently located ... to send money to and you're ready to make t
2008 Mazda Tribute ... noise coming from the right side of the engine near the
idler pulley. Cause: ... pulley by holding the probe to one of the idler pulley bolts.
2003 – 2004 Ford Expedition and. 2003 – 2004 Lincoln Navigator. Condition: ...
and the wiring harness replaced with the appropriate harness indicated in the.
TECH TIPS Dixie Part Numbers:
A-2066
Applications:
2003 – 2004 Ford Expedition and 2003 – 2004 Lincoln Navigator
Condition: Some of the above vehicles may experience some or all of the following conditions: - Intermittent vehicle performance issues - Intermittent illumination of the charge warning light. - Diagnostic codes P0620 and or P0320 stored in the memory of the vehicles PCM. Cause: These conditions could be caused either by chafing or corrosion of the wiring harness (reference 14305) or communication between the PCM and the charging system. Correction: On vehicles built prior to April 2nd, 2004 the PCM will need to be reprogrammed and the wiring harness replaced with the appropriate harness indicated in the table below. WARNING BEFORE APPLYING DIELECTRIC GREASE VERIFY IF THE HARNESS ALREADY HAS GREASE. Harnesses with the engineering identification 2L1T-AL, 2L7T-AL, 4L1T-AC or 4L7T-AC or with higher suffixes are already pre-greased and additional grease could damage the connectors. Application Expedition Expedition Navigator Navigator
Production Date March 18, 2002 to January 31, 2003 February 1, 2003 to April 2, 2004 March 18, 2002 to January 31, 2003 February 1, 2003 to April, 2004
On vehicles built from March 2, 2004 to June 14, 2004 will need the PCM reprogrammed and the dielectric grease applied as noted above. On vehicles built from June 15, 2004 to July 19, 2004 the PCM will require reprogramming. DO NOT REPLACE THE ATERNATOR UNLESS IT IS DIAGNOSED AS FAULTY.
REV: 20090330 Courtesy of APRA TSB_201.doc Dixie Tech Tips are intended for use by professional technicians, and are not for the general public. They are written to inform technicians of conditions that may exist or as a guide to aid in diagnosing and servicing a vehicle. All references to original equipment manufactures, vehicle manufactures and any other Trade Mark names are for the sole purpose of identifying the vehicle and or part that the Tech Tip applies to. This document is property of Dixie Electric Ltd. and is not to be copied or distributed with out written permission.
