Digital radio DAB Digital radio DAB Installation instructions ...

Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Instruction No 31266810

Version 1.1

V70 2011 V70 (08-) 2011 Volvo Cars Europe

Part. No. 31266809

Digital radio DAB

IMG-295623

© Volvo Car Corporation

Digital radio DAB- 31266810 - V1.1

Page 1 of 13

Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden


Equipment

IMG-242205

A0000162

IMG-239664

IMG-285783



Page 2 of 13



IMG-213320



Page 3 of 13



INTRODUCTION Read through all of the instructions before starting installation. Notifications and warning texts are for your safety and to minimise the risk of something breaking during installation. Ensure that all tools stated in the instructions are available before starting installation. Certain steps in the instructions are only presented in the form of images. Explanatory text is also given for more complicated steps. In the event of any problems with the instructions or the accessory, contact your local Volvo dealer.

Note! Some steps in these installation instructions are presented with illustration only.

Installation S80

1

Installation S80

Turn the ignition key to position 0.

Note! Wait at least three minutes before unplugging the connectors or removing other electrical equipment.

IMG-245980



Page 4 of 13



2

IMG-226720

3

IMG-285807

4 Take the adapter cable marked A from the kit and connect the large connector to the receiver. Secure the loose connectors with their clips in the holes respectively edges in the bracket.

IMG-295624



Page 5 of 13



5 Insert the two legs of the bracket in the corresponding recesses in the backrest bracket and lower it over the retaining pin in the floor.

IMG-285808

6 Tighten the bracket using plastic nuts from the kit. Connect the pre-routed wiring for power supply, fibre-optics and the two antenna cables to the receiver. The pre-routed cables are located under the insulation close to the location for the bracket.

IMG-285809

7

IMG-226908



Page 6 of 13



8 Download software for DAB (Digital Audio Broadcast) according to the service information in VIDA.

IMG-242268

V70, XC70

Note! On cars with subwoofers, a fibre-optic adapter cable (marked B in the kit) is required to connect to the DAB receiver.

9 Note! Wait at least three minutes before unplugging the connectors or removing other electrical equipment. Turn the ignition key to position 0.

IMG-245980



Page 7 of 13



10 Fold up the luggage compartment floor. Disconnect it from the mountings at the front edge. Pull out the luggage compartment floor and the storage box slightly to access the area behind the backrest.

Note! Note the luggage compartment floor's gas strut.

IMG-262243

11

Applies to cars with subwoofer Remove the rear plastic nuts for the subwoofer. Fold the backrest forward.

IMG-261926

12 Disconnect the connectors from the subwoofer. Remove the screw from the right-hand mounting.

IMG-261927



Page 8 of 13



13 Remove the screw from the left-hand mounting.

IMG-261928

14

IMG-261929

15

IMG-285807



Page 9 of 13



16 Take the adapter cable marked A from the kit and connect the large connector to the receiver. Secure the loose connectors with their clips in the holes respectively edges in the bracket.

IMG-295624

Installation, V70, XC70

17

Installation, V70, XC70

Install the DAB unit with bracket on the reverse of the rear backrest. Install the screws and tighten to 10 Nm (7.5 lbf.ft.).

IMG-295625



Page 10 of 13



18 Connect the wiring for the power supply, fibre-optics and the two antenna cables to the receiver. They are located near to the location for the bracket. Applies to cars with subwoofer If the car has a subwoofer a fibre optic adapter cable must be used to connect the units. See step 19.

IMG-295626

19

Applies to cars with subwoofer

IMG-261932

20

IMG-261934



Page 11 of 13



21

IMG-261935

22 Take the fibre optic adapter cable from the kit and connect the male connector (1) to the fibre optic cable, which was disconnected from the subwoofer, to the female connector (2) on the adapter cable. Connect the remaining connectors on the fiber optic cables for the subwoofer and DAB unit. Connect the remaining connector that was disconnected from the subwoofer. Ensure that the cables are positioned so that they are not at risk of being cut off.

IMG-295628

23

IMG-261936



Page 12 of 13


24


Applies to all models

IMG-262244

25 Download software for DAB (Digital Audio Broadcast) according to the service information in VIDA.

IMG-242268



Page 13 of 13