service manual personal audio system - MiniDisc Community Page

ZS-D5 SERVICE MANUAL

US Model Canadian Model AEP Model UK Model E Model

Ver 1.3 2000.2 With SUPPLEMENT (9-923-270-82)

CD

Model Name Using Similar Mechanism New

Section

Optical Pick-up Name

Tape deck

Model Name Using Similar Mechanism PMC-303

Section

Tape Transport Mechanism Type

KSM-213CDM/M-S

MF-D55-144

SPECIFICATIONS AUDIO POWER SPECIFICATIONS POWER OUTPUT AND TOTAL HARMONIC DISTORTION With 3-ohm load, both channel driven from 150 - 15,000 Hz; rated 3 W per channelminimum RAM power, with no more than 10 % total harmonic distortion in AC operation. Other Specifications CD player section System Compact disc digital audio system Laser diode properties Material: GaALAs Wave length : 780 nm Emission duration: Continuous Laser output: Less than 44.6 µW (This output is the value measured at a distance of about 200 mm from the objective lens surface on the optical pick-up block with 7 mm aperture.) Spindle speed 200 r/min (rpm) to 500 r/min (rpm) (CLV) Number of channels 2 Frequency response 20 - 20,000 Hz +0/-1dB Wow and flutter Below measurable limit

Radio section Frequency range US, Canadian AEP, UK, E

Aerials

MICROFILM

FM: 87.6 - 108 MHz AM: 530 - 1,710 kHz FM: 87.5 - 108 MHz (Italy) FM: 87.6 - 107 MHz (Other countries) MW: 531 - 1,602 kHz LW: 153 - 279 kHz FM: Telescopic aerial AM: Built-in ferrite bar aerial

Cassette-corder section Recording system 4-track 2 channel stereo Fast winding time Approx. 120s (sec.) with Sony cassette C-60 Frequency response TYPE1 (normal): 50 - 15,000 Hz General Speaker

Full range: 8 cm (3 1/4in.) dia., 3 Ω, cone type x 2 Input LINE IN jack (stereo minijack) Minimum input level 250 mV Outputs Headphones jack (stereo minijack) For 16 - 68 Ω impedance headphones LINE OUT jack (stereo minijack) Rated output level 250 mV at load impedance 47 kΩ OPTICAL DIGITAL OUT (CD) (optical output connector) Wavelength: 630 - 690 nm Power output (excluding U.S. model) 4.5 W + 4.5 W (3 ohms at 10 % harmonic distortion in DC operation) Power requirements For personal component system: 120 V AC, 60 Hz 12 V DC, 8 size D (R20) batteries For memory back-up: 6 V DC, 4 size AA (R6) batteries For remote commander: 3 V DC, 2 size AA (R6) batteries Power consumption AC 25 W — Continued on next page —

PERSONAL AUDIO SYSTEM

TABLE OF CONTENTS

SAFETY CHECK-OUT

1. SERVICE NOTE ............................................................... 3

After correcting the original service problem, perform the following safety checks before releasing the set to the customer: Check the antenna terminals, metal trim, “metallized” knobs, screws, and all other exposed metal parts for AC leakage. Check leakage as described below.

2. GENERAL .......................................................................... 4 3. DISASSEMBLY 3-1. 3-2. 3-3. 3-4. 3-5. 3-6.

Front Cabinet Assy ........................................................... 12 Mechanisum Assy ............................................................. 13 Control Board, Lump Board, H/P Board .......................... 14 CD Block Assyt, Handole ................................................ 14 Main Board, Optical Pick up ............................................ 15 Tuner Board, Power Board, Rear Cabinet ........................ 15

4. TEST MODE ..................................................................... 16

LEAKAGE The AC leakage from any exposed metal part to earth ground and from all exposed metal parts to any exposed metal part having a return to chassis, must not exceed 0.5 mA (500 microamperes). Leakage current can be measured by any one of three methods.

5. MECHANICAL ADJUSTMENTS ............................. 16 1.

A commercial leakage tester, such as the Simpson 229 or RCA WT-540A. Follow the manufacturers’ instructions to use these instruments.

2.

A battery-operated AC milliammeter. The Data Precision 245 digital multimeter is suitable for this job.

3.

Measuring the voltage drop across a resistor by means of a VOM or battery-operated AC voltmeter. The “limit” indication is 0.75 V, so analog meters must have an accurate low-voltage scale. The Simpson 250 and Sanwa SH-63Trd are examples of a passive VOM that is suitable. Nearly all battery operated digital multimeters that have a 2V AC range are suitable. (See Fig. A)

6. ELECTRICAL ADJUSTMENTS ............................... 17 7. DIAGRAMS 7-1. 7-2. 7-3. 7-4. 7-5. 7-6. 7-7. 7-8. 7-9. 7-10. 7-11. 7-12. 7-13. 7-14. 7-15. 7-16. 7-17. 7-18.

Circuit Boards Location ................................................... 20 Brock Diagrams – Tuner/CD Section – ........................... 21 Brock Diagrams – TC Section – ...................................... 23 Printed Wiring Board —Main Section — ........................ 26 Schematic Diagram —Main Section (1/2) — .................. 29 Schematic Diagram —Mainl Section (2/2) — ................. 32 Printed Wiring Board —Power Section — ...................... 35 Schematic Diagram —Power Section — ......................... 37 Printed Wiring Board —Control/Switch Section — ........ 39 Schematic Diagram —Control/Switch Section — ........... 43 Printed Wiring Board —Tuner Section (US, CND model) — ............................ 45 Schematic Diagram —Tuner Section (US, CND model) — ............................ 47 Schematic Diagram —Tuner Section (AEP, IT, UK, E model) — ................... 50 Printed Wiring Board —Tuner Section (AEP, IT, UK, E model) — ................... 53 Schematic Diagram —TC Section — .............................. 55 Printed Wiring Board —TC Section — ........................... 57 IC Pin Function ................................................................ 58 IC Brock Diagrams ........................................................... 60

To Exposed Metal Parts on Set

8. EXPLODED VIEWS 8-1. 8-2. 8-3. 8-4. 8-5. 8-6.

0.15 µF

Cabinet Section ................................................................. 64 Rear Cabinet Section ........................................................ 65 CD Mechanism (KSM-213CDM/M-S) ............................ 66 Optical Pick up ................................................................. 67 Cassette Mechanism Deck Section-1 (MF-D55-144) ...... 68 Cassette Mechanism Deck Section-2 (MF-D55-144) ...... 69

1.5 kΩ

AC Voltmeter (0.75 V)

Earth Ground

9. ELECTRICAL PARTS LIST ........................................ 70

Fig. A. Using an AC voltmeter to check AC leakage.

Battery life For CD radio cassette-corder FM recording Sony R20P: approx. 6 h Sony alkaline LR20: approx. 12h Tape playback Sony R20P: approx. 3h Sony alkaline LR20: approx. 6h CD playback Sony R20P: approx. 1.5 h Sony alkaline LR20: approx. 3h Dimmensions (incl. projecting parts) Approx. 416 x 198.5 x 246 mm (w/h/d) (16 1/2 x 7 7/8 x 9 3/4 inches) Mass (incl. batteries) Approx. 5.2 kg (11 lb. 7 oz) Supplied accessories AC power cord (1) Remote commander (1) Design and specifications are subject to change without notice.

SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.

ATTENTION AU COMPOSANT AYANT RAPPORT À LA SÉCURITÉ! LES COMPOSANTS IDENTIFÉS PAR UNE MARQUE ! SUR LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈSES SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU DANS LES SUPPÉMENTS PUBLIÉS PAR SONY.

—2—

SECTION 1 SERVICING NOTE NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK OR BASE UNIT

The laser component in this product is capable of emitting radiation exceeding the limit for Class 1.

The laser diode in the optical pick-up block may suffer electrostatic breakdown because of the potential difference generated by the charged electrostatic load, etc. on clothing and the human body. During repair, pay attention to electrostatic breakdown and also use the procedure in the printed matter which is included in the repair parts. The flexible board is easily damaged and should be handled with care. This appliance is classified as a CLASS 1 LASER product. The CLASS 1 LASER PRODUCT MARKING is located on the rear exterior.

NOTES ON LASER DIODE EMISSION CHECK The laser beam on this model is concentrated so as to be focused on the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens.

The following caution label is located inside the unit.

CHUCK PLATE JIG ON REPAIRING On repairing CD section, playing a disc without the CD lid, use Chuck Plate Jig. • Code number of Chuck Plate Jig : X-4918-255-1

CAUTION Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous radiation exposure.

LASER DIODE AND FOCUS SEARCH OPERATION CHECK 1. 2. 3. 4.

Press CD open knob. Open the lid for CD. Push on SWITCH as following figure. Confirm the laser diode emission while observing the objecting lens. When there is no emission, Auto Power Control circuit or Optical Pick-up is broken. Objective lens moves up and down once for the focus search. Insert a precision screw driver and push SWITCH

—3—

SECTION 2 GENERAL

This section is extracted from instruction manual.

LOCATION OF PARTS AND CONTROLS 12345678

@™

@¡ @º !• !§

9 !ª

!¡

!¶

!º !™

!∞

!¢

1 2 3 4 5 6 7 8 9 0 !¡

!£

MEGA BASS button SOUND button STANDBY button SLEEP button CLOCK button PROGRAM AUTO PRESET CHECK button MODE MONO/ST ISS button CANSEL button VOL button EDIT button DISPLAY ENTER button

!™ !£ !¢ !∞ !§ !¶ !• !ª @º @¡ @™

TUNE/TIME SET button MD (LINE) button OPTICAL DIGITAL OUT (CD) r/P button COUNTER RESET button DIR MODE button TIMER button Remote sensor OPR/BATT lamp POWER button 2

@£

@∞

@¢ @§ @¶

@§ TAPE buttons @¶ PUSH OPEN/CLOSE (CASSETTE)

@£ PUSH OPEN/CLOSE (CD) @¢ CD button @∞ RADIO buttons

—4—

—5—

—6—

—7—

—8—

—9—

— 10 —

— 11 —

SECTION 3 DISASSEMBLY ZS-D5

FRONT CABINET ASSY

CD BLOCK ASSY, HANDLE

MECHANISM DECK ASSY MAIN BOARD, OPTICAL PICK UP

CONTROL BOARD, LAMP BOARD, H/P BOARD

TUNER BOARD, POWER BOARD, REAR CABINET

Note : Follow the disassembly procedure in the numerical order given.

3-1.

FRONT CABINET ASSY

6 Front cabinet assy 3 Connector(CN306)

4 Connector (CN801)

2 Screws (+BVTP 3 ×12)


5 Rear cabinet assy 1 Battery lid 2 Screws (+BVTP 3 ×12)

— 12 —

3-2.

MECHANISM ASSY Rear cabinet assy


!£ MD chassis !º TC board

2 Connector (CN301)

8 Connector (CN402) !™ MF-D55-144 9 Screws (+BVTP 3 ×10) !¡ Screws (+BVTP 3 ×10) 5 Connector (CN401)

4 Connector (CN442)

3 Connector (CN441) 1 Screw (+BVTP 3 ×10) 7 Terminal board

6 Screws (+BVTP 2.6 ×10)

— 13 —

3-3.

CONTROL BOARD, LAMP BOARD, H/P BOARD Rear cabinet assy

0 H/P board 8 Connector (CN305)

9 Screw (+BVTP 3 ×10)

7 LANB board

5 Screws (+BVTP 2.6 ×10) 6 Connector (CN804) 2 Connector (CN802)

3 Screws (+BVTP 2.6 × 10)

4 CONTROL board

1 Connector (CN803)

3-4.

CD BLOCK ASSY, HANDLE 1 Screws (+BVTP 3 ×10)

2 CD block assy 4 Handle


— 14 —

3-5.

MAIN BOARD, OPTICAL PICK UP 4 Screws (+BVTP 3 ×10) 4 Screws (+BVTP 3 ×10)

5 MAIN board

1 Connector (CN701)

2 Connector (CNP703)

Optical pick up KSM-213CDM 3 Connector (POSH SWITCH)

CD chassis

3-6. TUNER BOARD, POWER BOARD, REAR CABINET 7 Connector (CN904) 0 Rear cabinet


5 TU cassis

4 TUNER board 2 Connector (CN1)

8 Screws (+BVTP 3 ×10) 6 Connector (CN901)


9 POWER board


— 15 —

SECTION 4 TEST MODE

SECTION 5 MECHANICAL ADJUSTMENT

1. HOW TO ENTER THE TEST MODE

PRECAUTION 1.

Turn on the main power. While the machine is in the CD STOP state, short-circuit JW824 and JW825 on the SWITCH board once. (Turn off the main power to exit the test mode.) [SWITCH Board] – Soldering Side –

2. 3. 4.

Clean the following parts with a denatured-alchool-moistened swab: record/playback head pinch roller erase head rubber belts capstans Do not use a magnetized screwdriver for the adjustments. After the adjustments, apply suitable locking compound to the parts adjusted. The adjustments should be performed with the raged power supply voltage unless otherwise noted.

Torque Measurement Mode

Torque Meter

FWD FWD back tension

JW825 JW824

2. RF Level and Jitter Check • Measurement Point MAIN board (see page 9) Vref (JW126) and RF Signal (JW135) (Confirm by oscilloscope)

REV REW back tension FF • REW

• Procedure (1) Press the CD key → Press the DISPLAY ENTER MEMORY key. (2) Confirm that display on LCD changes as follows. F–

–F

CHECK

CQ-102RC

CQ-201B

Torque Meter

ALL

88 88

FWD

CQ-403A

REV

CQ-403R

(Indication that automatic adjustment is completed) (3) Press the EDIT key. (APC OFF)

36 to 61 g•cm (0.504 to 0.854 oz•inch) 2 to 6 g•cm (0.028 to 0.084 oz•inch) 36 to 61 g•cm (0.504 to 0.854 oz•inch) 2 to 6 g•cm (0.028 to 0.084 oz•inch) 61 to 143 g•cm (0.854 to 2.002 oz•inch)

Tape Tension Measurement Mode

CHECK

CQ-102C

Meter Reading

88 88 The display ALL disappears.

(4) Confirm that jitter is 9.0 ns or less. Confirm also that the RF level is from 0.9 to 1.3 Vp-p.

0.9 to 1.3 Vp-p

0V

3. Traverse Signal Check • Measurement Point: MAIN board (see page 9) Vref (JW126) and TE Signal (IC701 pin $¶) (Confirm by oscilloscope) • Procedure (1) Press the = or + key. (2) Check that the traverse level is from 0.3 to 0.5 Vp-p. A=B A+B= 0.3 to 0.5 Vp-p

— 16 —

Meter Reading more than 100 g•cm (more than 1.38 oz • inch) more than 100 g•cm (more than 1.38 oz • inch)

ZS-D5

SECTION 6 ELECTRICAL ADJUSTMENT PRECAUTION 1. Perform adjustments in the test mode. 2. Demagnetize the record/playback head with a head demagnetizer. 3. Do not use a magnetized screwdriver for the adjustments. 4. After the adjustments, apply suitable locking compound to the parts adjust. 5. The adjustments should be performed with the rated power supply voltage unless otherwise noted. 6. The adjustments should be performed in the order given in this service manual. (As a general rule, playback circuit adjustment should be completed before performing recording circuit adjustment.) 7. The adjustments should be performed for both L-CH and RCH. • Standard Record: Deliver the standard input signal level to the input jack and set the VOLUME +/– keys to obtain the standard input and output signal level. •

within 1dB

output level

Screw position

R-CH peak

Put the lead-wire antenna close to the set.

+

LINE OUT L-CH peak

Screw position

R-CH peak

3.

3. Phase Check Mode: REV playback oscilloscope

H.P OUT 32 0.10 V (-18 dB)

FM Tracking

• FM section

H

L4: AM Reception Frequency coverage

22.5 kHz frequency deviation by 400 Hz signal

47 kΩ

[AEP/IT/UK/E model] Output level: as low as possible

Oscilloscope Lissajous pattern

Test Tape P-4-A100 WS-48A

in phase

Signal

Used for REC/PB/ERASE Head azimuth 10 kHz, -10 dB and phase adjustment. 3 kHz, 0 dB

Tape speed adjustment

TAPE RECODER SECTION

0 dB = 0.775V

Record/Playback Head Azimuth Adjustment Note: • Start adjustment after head has changed the direction. (When head is positioned in the FWD direction of tape running, start adjustment with REV .) • The adjustment must be ended with cw turning of adjustment screw.

45°

good

LW Tracking

VTVM

90°

135°

CT5

4. Repeat steps 1 to 3 FWD playback mode. 5. Check that phase difference between L-CH and R-CH is from o to 90 degrees. 6. After the adjustments, apply suitable locking compound to the pats adjusted.

HEADPHONES

•

Repeat the proceduresin each adjustment several times for the maximum level meter indication. The frequency coverage and tracking adjustments should be finally done by the trimmer capacitors.

• (

CT3: LW Reception Frequency Coverage CT1 FM Tracking L1

IC701 JW135

) : US/Canadian model

JW126

MW/AM RECEPTION FREQUENCY COVERAGE CHECK 531 kHz 1,611 kHz Frequency indication (530 kHz) (1,710 kHZ) Digital voltmeter reading

Adjustment Location:

Adjustment

0.6 to 1.2 V (0.9 to 1.0 V) L4

4.5 to 5.5 V (5.2 to 6.2 V) check

L2: FM Reception Frequency Coverage

LW RECEPTION FREQUENCY COVERAGE CHECK Frequency indication 151 kHz 273 kHz Digital voltmeter reading 0.6 to 0.7 V 4.7 to 5.7 V Adjustment CT3 check

level meter 47 kΩ

+ –

Adjustment screw (FWD)

LINE OUT

— 17 —

Adjustment screw (REV)

(

) : US/Canadian model

MW/AM TRACKING ADJUSTMENT Adjust for a maximum defection of level meter. L3 CT2 621 kHz (620 kHz) 1,404 kHz (1,400 kHz)

— 18 —

CT2

L4

MW Reception Frequency Coverage

AEP/Italian/UK/E model

test tape P-4-A100 (10KHz, –10dB)

CT4 L3 (MW)

–

wrong

Note: Adjustment must be completed by cw turning of adjustment screw. After the adjustment, lock the screws with locking compound.

L3 (LW)

MW Tracking

+

set

180°

Procedure: 1. Mode : REV playback

set

CT1

Measurement Point: MAIN board (Side B)

LINE

Test tape

CT2

FM RF SSG

32 Ω

•

L3

L1

to FM RF (FM IN)

L-CH

AM Tracking

FM RECEPTION FREQUENCY COVERAGE CHECK Frequency indication 87.5 MHz 108 MHz Digital voltmeter reading 0.9 to 1.3 V 3.4 to 4.4 V Adjustment L2 check

FM TRACKING ADJUSTMENT Adjust for a maximum defection of level meter. L1 CT1 87.5 MHz 108 MHz

Output level: as low as possible

set

Standard output level

L2: FM Reception Frequency coverage

30% amplitude modulation by 400 Hz signal

Playback the standard tape in FWD mode. Adjust the variable resistor of the motor (M691) until frequency counter reading is from 2,985 to 3,015 Hz. Confirm that the freqency difference between the tape top and end is within 3 %.

47 kΩ V

10 kΩ 0.25 V (–9.8 dB)

1. 2.

[US/CND Model]

• AM Section

–

R-CH

SP OUT (L, R) 3.2 0.775 V (0 dB)

LW TRACKING ADJUSTMENT Adjust for a maximum defection of level meter. L3 CT5 162 kHz 261kHz

AM RF SSG

set

Adjustment Location: TUNER board (Side A)

AEP/Italian/UK/E model

0 dB = 1µV

frequency counter 100 kΩ

LINE IN

Output Pin Load impedance Output signal level

TUNER SECTION [Setting during adjustment] Function mode: RADIO VOLUME: Maximum

within 1dB

L-CH peak

Standard input level Input Pin

Tape Speed Adjustment Procedure: Mode : FWD playback test tape WS-48B (3 kHz, 0 dB)

test tape P-4-A100 (100 kHz, –10 dB)

Signal source impedance Input signal level •

2. Turn the adjustment screw and check output peaks. If the peaks do not match for L-CH and R-CH, turn the adjustment screw so that outputs match within 1dB of peak.

— 19 —

ZS-D5

7-2.

BLOCK DIAGRAM

— TUNER/CD SECTION —

CIRCUIT BOARD LOCATION AU7.5V

CF3

FM/AM FRONT-END IC1

ANT1 FM TELESCOPIC ANTENNA

CF4

9

13

CD MOTOR board

5

VCC1 VCC2

Q23(AEP,IT,UK,E) Q18(US,CND)

FL1 B.P.F

1 L1

MAIN board

22

VCO

QUAD

AU7.5V

23

FM RF I

MIX OUT

FM MIX

CF1

3

CF2

RF IF AMP

6

FM IF

FM DET

FM RF O

FM/AM BUFFER CFT1

D1

7

AM IF

MPX

17

FM MPX

16

L-CH

11

MUTE

12

A

TO TC SECTION

R-CH

AM DET ST IND

FM OSC

BAND

PLL 14 IC2(AEP,IT,UK,E) Q12(AEP,IT, IC3(US,CND) UK,E) Q3(US,CND)

15

D2 L2 AEP,IT,UK,E Model

L3 FERRITE-ROD ANTENNA

L3 FERRITE-ROD ANTENNA 24

Q1 BUFFER

Q13

PD1

24

AM RF

19

17 FM

AM MIX

P1

16 AM

D5 AU7.5V

Q5

LAMP board

18 VDD 22

Q4 22

AM OSC

AM OSC

AM OSC

MUTE SWITCH Q18 Q10(AEP,IT, UK,E) Q2(US,CND)

CD 7 DA 6

PLL L.P.F

Q21

21 PD1

CK

5

CE 4 Q19(US,CND) Q14(AEP,IT,UK,E)

TC board

+B

TU7.5V H FREQ CUT

AEP,IT,UK,E


2 XI

Q3 LW-H

8


IF 14

X1 75kHz


US,CND Model

Q6 AU7.5V

1 XO

AU7.5V

MW-H Q22

P0

Q16 MUTE

AU7.5V

9

TU5V Q2

Q15 MUTE

18

D3

IC 1

SW board

OSC AM RF

10

IF BUFFER

FM OSC

MO/ST

CONTROL board

21

PD1

MW-H

Q22 INV.

10 MW-L

LW-H

INV.

11 LW-L

CD


DA CK

TU5V

CE

Q21

TERMINAL board AEP,IT,UK,E Model

OPTICAL PICK-UP BLOCK (KSM-213CDM/M-S)

CD5V CD5V

CD RF/SERVO PROSSESOR IC701

VCC

18

CD5V

PCMD

PD1

33

44

27

23

24

14

25

13

RF

SERIAL/ PARALLEL CONVERTER DECODER

F F

41

Q701 LD

LD/POWER CONTROL

36

F

DATA TTL IIL

LD

XLT CLK XRST LOCK

15

21

16

37

PD

FOCUS PHASE COMPENSATION

CN SE

SUB CODE PROSSESOR

CLV SERVO

B

TO TC SECTION

R-CH

XTAI 89

DAT

CPU I/F

CLK

17

23

100 XRST

19

29

22

XTAO 90

XLT

20

18

PD

95

L-CH

X701

22

COMAND

APC

AR

84

FOK

26

27

GND

PWM

AL

LOCK MDP

DIGITAL CLV

XLON SPOA

TRACKING PHASE COMPENSATION

9 75

SYSM

TTL

SENS 2

73

PWM SERIAL I/F

10 11 12 7

8

6

5

8 11

12 9

1

7

B MUTE

FE AMP

SENS 1

72

SENS

E

51

SCOR

42

55

50

C SCOR

E

53

54

SQSO

IIL

E

52

C SENSE1

FOK C OUT

CLOCK

PD2

D

SQCK

39

D

EMPH

EFM DEMO.

XLAT

RFO

B B

BCK LRCK

C CLK

RF AMP

C

DATA

38

D/A I/F

C

BATTERY(S)board

1 D IN

C XLAT

H/P board

71

3 GND

51 VC

A

BATTERY(L)board

D OUT

VCC

VC A

POWER board

IC441 2 VDD

CD DIGITAL SIGNAL PROCESSOR IC702

C DATA

80

VR F/T COIL SL/SP MOTOR DRIVER IC703

TEO

13

SLO

16

10 F+ F IN 11

F

9 F 21 R ST

T+ TRACKING COIL

7

T+ T IN 4

T

16

6

CD DA

T

CK

SWITCH board

CE

TUNER board

M702 SLED MOTOR

25 R CONT

:CD :DIGITAL OUT

24 R CE IC801(1/2) SYSTEM CONTROL 13 C SENSE2

22 SP+ SP IN 25

M 21 SP

MUTE 15 S701 LIMIT

— 20 —

— 21 —

• R-CH:Same as L-CH • Abbreviation

4 C XRST M701 SPINDOL MOTOR

:FM

22 R CLK

SL IN 29 27 SL

• SIGNAL PATH

23 R DATA

28 SL+

M

C SQSO

F+ FOCUS COIL

FEO

6

C SQCK

7-1.

SECTION 7 DIAGRAMS

— 22 —

CND

: Canadian

IT

: Italian

OPTICAL DIGITAL OUT

ZS-D5 — TC SECTION —

LINE AMP IC305 5 J441 LINE IN

Q105

Q103

MUTE CONTROL

A B

LINE OUT

• SIGNAL PATH :FM

MUTE PB/REC FUNCTION IC401

Q320,329

FROM TUNER/CD SECTION

J442

R-CH

7

Q107

R-CH

SOUND/VOLUME IC302 4

TU L

22

CD L

24

Q104

6

7

8

Q106

MUTE CONTROL

MUTE

D441

:CD

S441 LINE

:PB (MD)

TAPE

L

20

9

VR

2

12

TAPE

D304

:LINE

J301

R-CH

MATRIX SURROUND

2

:REC (MD)

POWER AMP IC304

TONE

LINE

Q321 CD/LINE CONTROL

5

Q326,327

RADIO

PHONES • R-CH :Same as L-CH

STBY

17 LINE/TUNER

12

5

D303 CD5V

Q325

13

NAB 5

D401

16

23

T401

CLK

TAPE 15

R

Q313,314 STBY SWITCH

19 20 18

D811

Q324

D402

AU7.5V

AUDIO MUTE

PB/REC SWITCH

ERASE

DATA

REC 21 Q406,408,409 Q411,413

VC

R-CH

L SPEAKER

4 R-CH

D306

BASS DET

21

14

REC

L-CH

BC

CONTROL

LATCH

M/D HEAD

Q403

4

Q328

OPR/ BATT AMS IC303

S817,825-830 FUNCTION SWITCH

6

AMS MUTE

BIAS OSC

1

LOGIC 2

Q405,410

S818-823 FUNCTION SWITCH

5

Q401

D301 R+B

S809-816

BIAS SWITCH

FUNCTION SWITCH

Q402

+B (IC304)

S801-807

AU7.5V

FUNCTION SWITCH ISS CONTROL

CD 8.5V MO 8.5V

REG Q902

AU 7.5V

REG Q901

D803 Q101

Q323

S691 HALF

Q301

D809 D810 RA5V

D361 Q322 PM691

LED DRIVE

D807

LED DRIVE

D805

Q362 Q363

Q365 PL DRIVE

MO 8.5V BU +B

PH691 END DET

COM5V

3

BACK-UP 5V REG

2

1

3

RESET IC803

SXXX OPEN/CLOSE

1

S696 HEAD POSITION

1

REG Q315

COM5V

2

IR RECEIVER

T901 POWER D901-904 TRANSFORMER

Q316,317

IC802

Q361

IC309

WAKE-UP CONTROL

MOTOR DRIVE

D806 CD5V

BU +B

Q805

S695 ERASE PROOF (SIDE B)

M Q318,319

D801

S694 ERASE PROOF (SIDE A)

M691 TAPE SPEED

D808

D802

S692 TYPE II (CrO2)

PB EQ SWITCH

RMC +B REG CHK

2

D314

OSC Q803,804

VR DATA

VR CLK

P CONT

8.5V CHK

A MUTE

34

REG CHK

T MOTOR CONT

2

RMC

TAPE END

3

RESET

PL CONT

WP

TAPE

39 OSC OUT

38

IC801(2/2) SYSTEM CONTROL

40 OSC IN

D905

D907 MAIN BATT UM1.5Vx8 12V

Q311,312

B/L CONT 84

37 R SHIFT X801 4.21MHz

27 33 32 31 30 99 KEY1

REC

93 CLK IN

17

KEY2

CD

92 CLK OUT X802 32.768kHz

16 19 20 28

KEY3

10

AMS

96 97 98

SEG0

54

SEG26

80

COM0

50

COM3

53

B/L SWITCH

PL801,802 LCD BACK LIGHT

D906 BACK-UP BATT UM1.5Vx4 6V

LCD801 LIQUID CRYSTAL DISPLAY PANEL

16

— 23 —

— 24 —

AC IN

D313

3

KEY4

95

T HEAD POS

14

EP(B)

100

CD OP/CL

15

HALF

86

EP(A)

83

VR CE

88 87

J901

RECT

D311 85

RADIO

BLOCK DIAGRAM

LINE

7-3.

— 25 —

7-17. IC PIN FUNCTION DESCRIPTION • IC801 CXP83124A-021Q Pin No.

Pin Name

I/O

1

C-SCOR

I

Description

2

REG-CHK

I

3

RMC

I

Remote control input signal

4

C-XRST

O

CD-system reset

5

C-XLAT

O

CD DSP for command latch

6

C-DATA

O

CD DSP command date output

7

B-MUTE

O

CD and TUNER mute output

8

C-CLK

O

CD DSP for command CLK output

CD DSP command date output

9

C-SENSE 1

I

CD SENSE input

10

P-CONT

O

Regulator control

11

C-SQCK

O

CD SUB-Q read-out clock

12

C-SQSO

O

CD-SQSO data input

13

C-SENSE 2

I

CD SENSE input

14

T-MOTOR CONT

O

15

PL-CONT

O

16

HALF (M/D)

I

17

T-HEAD POS

I

18

NC

–

Not used (open)

19

Write protect (A)

I

Write protect (A)

20

Write protect (B)

I

Write protect (B)

Tape exist/not exist check

21

R-ST

I

Tuner stereo receive signal

22

R-CLK

O

PLL IC clock output

23

R-DATA

O

PLL IC data output

24

R-CE

O

PLL IC chip enable output

25

R-CONT

I

PLL IC data input

26

–

–

Not used (open)

27

AMS

I

28

CD-OP/CL

O

29

NC

–

Not used (open)

30

KEY 1

I

Key input

31

KEY 2

I

Key input

32

KEY 3

I

Key input

33

KEY 4

I

Key input

34

+8.5V-CHK

I

DC voltage check

35

INIT

I

INITIAL

36

Destination

I

Destination Radio destination read-in input

37

R-SHIFT

O

38

RESET

I

Reset

39

OSC-OUT

I

4.19 MHz input

40

OSC-IN

O

4.19 MHz input

41

GND

–

Ground

42

NC

–

Not used (open)

43

NC

–

Not used (open)

44

V REF

I

45

GND

–

Ground

46

VDDL

I

LCD drive bias control terminal

47

VDD3

I

Bias power source supply terminal for LCD drive

48

VDD2

I


49

VDD1

I


50

COM0

O

LCD common output

— 58 —

Pin No.

Pin Name

I/O

51

COM1

O

LCD common output

Description

52

COM2

O

LCD common output

53

COM3

O

LCD common output

54 to 80

SEG0 to SEG26

O

LCD common output

81

NC

–

Not used (open)

82

NC

–

Not used (open)

83

REC

O

Record bias power source supply

84

B/L-CONT

O

B/L-CONTROL

85

LINE

O

LIFE FUNCTION output

86

TAPE

O

TAPE FUNCTION output

87

RADIO

O

RADIO FUNCTION output

88

CD

O

CD FUNCTION output

89

VDD

I

Power supply

90

NC

I

Not used (connected to VDD)

91

GND

–

Ground

92

CLK OUT

–

32 kHz output

93

CLK IN

–

32 kHz output

94

NC

–

Not used (open)

95

A-MUTE

O

AUDIO MUTE terminal

96

VR-DATA

O

VOLUME DATA output

97

VR-CLK

O

VOLUME CKL output terminal

98

VR-CE

O

VOLUME ENABLE output terminal

99

WP

I

µ-COM WAKE UP terminal

100

TAPE END

I

Tape end check

— 59 —

12 13 14 15 16

REG OUT

MUTE

FIN

VO1(–)

11

REG-B

VO1(+)

10

RESET

VIN1

9

VIN2

VIN1

8

VO2(+)

7

VO2(–)

6

GND

5

IC302 BH3854AS

— 60 —

LEVEL SHIFT REGULATOR BIAS T.S.D. MONITOR

LEVEL SHIFT

– 50K

+

10K

+

REGULATOR

13.3K

13.3K

LEVEL SHIFT

10K

+

BIAS

+

100

D.BUF

4 D.BUF

D.BUF

3

BIAS IN

+ –

–

D.BUF

2

Vcc

– + –

–

13.3K

13.3K

10K

1

NC

10K

D.BUF

D.BUF

D.BUF

D.BUF

10K

FIN

Vcc

VIN4

VIN4

VO4(–)

VO4(+)

NC

OP IN(–)

OP OUT

GND

VO3(–)

VO3(+)

VIN3

VIN3

GND

NC

7-18. BLOCK DIAGRAMS IC703 BA6898S

32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17

LEVEL SHIFT

OP-AMP

– DRIVER-MUTE

50K

+

IC3 BU2615S

IC1 TA2008AN 24

23

22

21

AM OSC

FM OSC

20

19

18

17

BUFF

IF BUFF

AF BUFF

16

15

14

13

FM MPX AM RF

BUFF

AM/FM ST/MONO SW

1/801V FM MIX

AM DET

AM MIX

AGC

FM RF

1

2

3

4

5

FM IF

AM IF

LEVEL DET

FM DET

ST DET

6

7

8

9

10

— 61 —

MUTE

11

12

FSTT 69 C4M 70

D/A Interface

EFM demodurator

SYSM

BCKI

PCMDI

Serial-In Interface

ASYI 46 ASYE 48

73 51 53 55 80

Error Corrector

RF 44

ASYO 47

LRCKI

BCK

62 63 49 50 52 54

EMPHI

PCMD

31

LRCK

RFCK

WDCK

TES0

65 66 67

osc

Clock Generator

C2PO

MNT0

68 34 33 35 36 37 58 59 61 72 74

MNT1

MNT3

WFCK

EMPH

GFS

XUGF

GTOP

VCTL

V16M

VCKI

VPCO2

VPCO1

XTSL

IC702 CDX2529Q

Asymmetry Corrector

6

XPCK 60

Digital PLL

FILI 40 PCO 38

3rd-Order Noise Shaper

Digital OUT

Sub Code Processor

PWM

CLTV 42

CPU Interface

LOUT2

AIN2

LOUT1

AOUT1

— 62 —

AOUT2

DOUT

IC303 LA2010

PWMI

85 84

XROF

86

LOCK

94 95

MDS

93

MDP

26 27 28 29 64 30 71 MON

EXCK

SQSO

SBSO

SCOR

XLON

SPOA~D

CLOK

XLAT

DATA

7 SQCK

Digital CLV

9 10 11 12 18~21 22 75 76 77 8 SENS

CLKO

15 16 17 XLTO

CNIN 14

Servo Auto Sequencer

DATO

FOK 23 SEIN 13

PWM

AIN1

FILO 39

LMUT

90 XTAO

Over Sampling Digital Filter

16K RAM

RMUT

3

89 XTAI Timing Logic

BIAS 45

4

CKOUT

RF_I

CP

CB

CC1

CC2

FOK

36

35

34

33

32

31

30

29

28

27

+ –

+ –

– +

– +

– + RF SUMMING AMP + –

PD1 IV AMP

PD2 IV AMP

VEE

RF_O

37

RF_M

PD0

38

RFTC

PD1

39

LD

PD2

IC701 CXA1992BR

+ – APC

VCC

SENS1

24

C OUT

23

XRST

22

DATA

21

XLT

20

CLK

19

LOCK

18

VCC

17

ISET

16

SL_O

15

SL_M

14

SL_P

TTL

+ –

FE AMP + –

+ –

VCC

– +

25

IIL

VEE LASER POWER CONTROL F IV AMP

E 42

SENS2

+ –

+ –

– +

F 41

26

+ –

VCC

+ –

FE_BIAS 40

VCC

+ –

E IV AMP

VEE

BAL3

VEE

IFB6

IFB5

IFB4

IFB3

IFB2

+ –

VEE

TOG4

IIL

TRK GAIN WINDOW COMP

FOK TTL

– +

FOH FOL TGH TGL BALH BALL ATSC TZC FZC

ATSC WINDOW COMP TZC COMP – +

TZC 49

DFCT1

CC1

MIRR

TGFL

LDON

+ –

LPC

E-F BALANCE WINDOW COMP

– +

ATSC 48

IIL

MIRR

+ –

+ –

TEI 47

VCC

LPCL

TOG3

VEE

+ –

+ –

+ –

TTL

+ –

TOG2

FO BIAS WINDOW COMP

TEO 45

+ –

VEE LEVEL 9

+ –

TOG1

+ –

VEE 44

LPF1 46

DFCT

+ –

TGFL

BAL2

+ – + –

BAL1

IFB1

BAL4

+ –

+ –

EI 43

IIL DATA REGISTER INPUT SHIFT REGISTER SENS SELECTOR OUTPUT DECODER

VCC

ISET

DFCT TM1 TRACKING PHASE COMPENSATION

TDFCT 50

DFCTO

TG1

VCC

IFB1-6 BAL1-4 TOG1-4

FS1-4

TG1-2

TM1-7

PS1-4

VCC TM4

+ – VEE FOCUS PHASE COMPENSATION

– +

TM3 VEE

FS1

VEE

TM2

DFCT

FDFCT

FGD

FLB

FE_O

8

— 63 —

VEE

9

10

11

12

13 TA_O

FEI

7

TA_M

6

FSET

5

TG2

4

TG2

TGU

3

SRCH

2

Charge up

FE_M

1

FSET

FS2

+ –

FS4

+ –

FZC COMP

FEO

FZC 52

TM7

VCC

TM5

VCC

TM6

+ –

VC 51

VCC

Ver 1.2 1999.10

SECTION 8 EXPLODED VIEWS NOTE: • -XX, -X mean standardized parts, so they may have some differences from the original one. • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • Abbreviation CND : Canadian IT : Italian

• •

The mechanical parts with no reference number in the exploded views are not supplied. Hardware (# mark) list and accessories and packing materials are given in the last of this parts list.

When indicating parts by reference number, please include the board name. The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié.

8-1. FRONT CABINET SECTION

7 6 #5

#5 #5

19

#4

#1

10 #1 5

#5

#2

13

#2

15

17 12

14

18

#1

16

#3

11 3 4

1 9 2

5 8 20

Ref. No.

Part No.

Description

1 2 3 4 5

X-3376-357-1 X-3376-361-1 3-017-465-01 X-3375-359-1 1-505-742-11

CABINET SUB ASSY, FRONT HOLDER SUB ASSY, JACK SPRING, CASSETTE OPEN HOLDER SUB ASSY, CASSETTE SPEAKER (8CM)

Remarks

6 7 8 9 * 10

1-501-480-11 3-017-470-01 3-017-473-01 3-017-877-11 A-3321-154-A

ANTENNA, TELESCOPIC LID, BATTERY CASE WINDOW, AZIMUTH PLATE (P), JACK SWITCH BOARD, COMPLETE (US,CND,E)

* 10 * 11 12

A-3321-191-A SWITCH BOARD, COMPLETE (AEP,IT,UK) 3-017-462-01 BRACKET, JACK 3-351-377-11 GEAR, DAMPER

Ref. No.

Part No.

Description

13 13 14 15 * 16

3-017-456-41 3-017-456-51 X-3376-363-1 3-017-457-11 3-017-461-01

BUTTON, POWER (US,E) BUTTON, POWER (AEP,UK) BUTTON SUB ASSY, CONTROL BUTTON, VOLUME BRACKET, OP/CLOSE

17 18 19 20

3-939-030-01 3-939-031-01 1-782-632-11 X-3374-296-1 3-014-503-01

CATCHER, PUSH SPRING, PUSH CATCHER RETURN WIRE, PARALLEL (FFC) (12 CORE) WINDOW SUB ASSY, LCD FOOT

*

— 64 —

3-703-044-26 LABEL, CAUTION (US,CND) 3-839-640-00 CUSHION

Remarks

8-2. REAR CABINET SECTION 54

55

64 #1

65

71 56 72

#1

52 70 F901

J301

57

#1 #4

T901

61 62

58

63

53 #2

70 #1 #2

#1

68

73

#2

66

67 #6

#1

73

73 60

not supplied #1

59 #1

51

73

MF-D55-144

#1

#2 Ref. No.

Part No.

Description

Ref. No.

Part No.

Description

51 51 52 52 53

1-666-855-11 1-666-855-21 A-3321-150-A A-3293-875-A 1-666-856-11

TERMINAL BOARD (US,CND) TERMINAL BOARD (AEP,IT,UK,E) POWER BOARD, COMPLETE (US,CND) POWER BOARD, COMPLETE (AEP,IT,UK,E) H/P BOARD (US,CND)

* 63 64 65 66 66

1-667-132-21 3-017-440-01 3-017-449-01 3-017-436-01 3-017-436-11

LAMP BOARD (AEP,IT,UK,E) BRACKET (L), HANDLE BRACKET (R), HANDLE CABINET, REAR (AEP,IT,UK,E) CABINET, REAR (US,CND)

* 53 54 * 55 * 55 * 56

1-666-856-21 3-017-448-01 1-666-860-11 1-666-860-21 1-666-861-11

H/P BOARD (AEP,IT,UK,E) HANDLE BATTERY (L) BOARD (US,CND) BATTERY (L) BOARD (AEP,IT,UK,E) BATTERY (S) BOARD (US,CND)

67 * 68 * 68 70 71

3-017-441-01 A-3293-842-A A-3293-869-A 1-533-233-21 3-017-439-01

TERMINAL, ANT TC BOARD, COMPLETE (US,CND) TC BOARD, COMPLETE (AEP,IT,UK,E) HOLDER, FUSE SPRING (-) (L), BATTERY

* 56 57 58 * 59 * 59

1-666-861-21 3-017-438-01 3-017-437-01 A-3321-151-A A-3321-189-A

BATTERY (S) BOARD (AEP,IT,UK,E) SPRING (+.-) (S), BATTERY SPRING (+.-) (L), BATTERY TUNER BOARD, COMPLETE (US,CND) TUNER BOARD, COMPLETE (AEP,IT,UK,E)

72 73 ! F901 ! F901 ! T901

3-939-057-01 SPRING (-), BACK UP 3-831-441-99 CUSHION, SPEAKER 1-532-505-31 FUSE (5A 250V) (AEP,IT,UK,E) 1-533-420-11 FUSE, GLASS CYLINDRICAL(DIA.5) (5A 125V) (US,CND) 1-431-483-11 TRANSFORMER, POWER (US,CND)

60 * 61 * 61 62 * 63

3-017-445-01 A-3321-148-A A-3321-186-A 3-017-443-01 1-667-132-11

CHASSIS, TU CONTROL BOARD, COMPLETE(US,CND) CONTROL BOARD, COMPLETE (AEP,IT,UK,E) BUTTON, SOUND LAMP BOARD (US,CND)

! T901 J301

1-431-484-11 TRANSFORMER, POWER (AEP,IT,UK,E) 1-566-891-11 JACK (H/P JACK)

* * * * *

Remarks

— 65 —

The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.

Remarks

Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié.

8-3. CD MECHANISM SECTION (KSM-213CDM/M-S)

102

104

#1

103

#1

118

101

118

#1 #1

105 not supplied

112

118 118 106

109

KSM-213 CDM

#1

111

111

107 110 117 #7

108 116

100

115

#1

114

#1

113

Ref. No.

Part No.

Description

Part No.

Description

* 100 * 100 101 102 103

A-3293-850-A A-3293-877-A 3-938-884-01 3-017-878-01 1-692-960-11

MAIN BOARD, COMPLETE (US,CND) MAIN BOARD, COMPLETE (AEP,IT,UK,E) SPRING, CD COIL SLIDER, PUSH SWITCH, PUSH (1 KEY)

Remarks

Ref. No. 109 110 111 112 113

3-351-377-11 3-931-379-21 3-931-379-31 3-910-116-01 1-782-629-11

GEAR, DAMPER RUBBER, VIBRATION PROOF RUBBER, VIBRATION PROOF COVER, CD WIRE, PARALLEL (FFC) (14 CORE)

104 105 106 107 108

3-017-450-01 3-017-472-11 1-452-732-11 3-016-397-01 3-911-135-01

SPRING, CD OPEN LID, CD MAGNET PLATE (KSM-213-CDM), CHUCKING SCREW (2.6X10), (+PWH) TAPPING

114 115 116 117 118

1-782-630-11 1-782-627-11 1-782-628-11 1-782-631-11 3-831-441-99

WIRE, PARALLEL (FFC) (13 CORE) WIRE, PARALLEL (FFC) (27 CORE) WIRE, PARALLEL (FFC) (20 CORE) WIRE, PARALLEL (FFC) (16 CORE) CUSHION, SPEAKER

— 66 —

Remarks

8-4. OPTICAL PICK UP SECTION

155

151

not supplied

152

#8

153 154

M702

Ref. No.

Part No.

! 151 152 153

8-848-483-05 OPTICAL, PIC-UP KSS-213C/Q-RP 2-627-003-02 GEAR (B) (RP) 2-626-908-01 SHAFT, SLED

Description

Remarks

Ref. No. 154 155 M702

Part No.

Description


— 67 —

Remarks

X-2626-202-1 CHASSIS ASSY (MB) (RP), MOTOR 2-626-907-01 GEAR (A) X-2625-769-1 GEAR ASSY (MB), MOTOR


8-5. CASSETTE MECHANISM DECK SECTION-1 (MF-D55-144)

216 215 214

209 211 208 HRPE101

213

207

217

212 210

220

205 206

204

222

221

223

218 227

203 202

Ref. No.

224 226

201

219

225

Part No.

Description

Remarks

Ref. No.

Part No.

Description

201 202 203 204 205

3-938-905-01 3-938-940-01 3-938-941-01 3-938-906-01 3-017-432-01

HEAD, LEVER SPRING (L) SCREW (A) AZIMUTH, SPRING SPRING (A)

* * * *

215 216 217 218 219

3-938-916-01 3-938-914-01 3-938-913-01 3-938-909-01 3-938-944-01

BRAKE, ARM FRAME (C) FRAME (B) LOCK, EJECT SCREW (D)

206 * 207 208 209 210

3-938-901-01 3-938-904-01 3-938-902-01 3-938-903-01 3-938-935-01

HEAD, HOLDER HEAD, FRAME WASHER SCREW SPRING (G)

220 221 222 * 223 224

3-017-591-01 3-938-937-01 3-938-938-01 3-938-911-01 3-938-907-01

ARM (PINCH R) ASSY SPRING (I) SPRING (J) HEAD (B), CHASSIS HEAD, GEAR ARM

211 212 213 214

X-3374-292-1 3-938-933-01 3-017-592-01 3-938-934-01

ASSIST ASSY, LEVER SPRING (E) ARM (PINCH L) ASSY SPRING (F)

225 3-938-943-01 226 3-938-942-01 227 1-662-743-11 HRPE101 1-500-480-11

— 68 —

SCREW (C) SCREW (B) HEAD BOARD HEAD, MAGNETIC (REC/PB/ERASE)

Remarks

8-6. CASSETTE MECHANISM DECK SECTION-2 (MF-D55-144)

267

M691

269 268

263 262

261 PM691

270 264

261 273

265 260

275

271

274

266

272 276 275

259

277

258 286

257

285

278

284

255

279 280 253 255 251 254 252

283

not supplied

282 281

256

Ref. No.

Part No.

Description

251 252 253 254 255

3-938-949-01 3-938-951-01 3-938-936-01 3-938-930-01 3-938-910-01

WASHER (B) WASHER (D) SPRING (H) SPRING (B) REEL, CAP

* 256 257 258 259 260

3-938-912-01 3-938-952-01 3-938-948-01 3-938-932-01 3-938-908-01

ARM (UD) WASHER (E) WASHER (A) SPRING (D) CASSETTE, SPRING

261 262 263 * 264 265

3-938-945-01 3-017-428-01 3-938-920-01 3-938-918-01 3-938-931-01

266 * 267 268 269

3-938-921-01 1-662-742-11 3-938-954-01 3-938-947-01

Remarks

Ref. No.

Part No.

Description

270 271 272 273 274

3-017-431-01 3-017-430-01 3-017-596-01 3-017-434-01 3-017-595-01

BRACKET (MM) BELT FLYWHEEL (R) ASSY SCREW (H) FLYWHEEL (L) ASSY

275 276 277 * 278 279

3-938-950-01 3-017-433-01 3-938-946-01 3-938-919-01 3-017-435-01

WASHER (C) SPRING (K) SCREW (F) ARM (FR) REFLECTOR

SCREW (E) FRAME (D) PLUNGER, K TRIGGER, ARM SPRING (C)

280 281 282 283 284

3-017-429-01 3-938-917-01 3-938-924-01 3-938-923-01 X-3374-293-1

GEAR (REF) GEAR (A) GEAR (P) GEAR (FR) CLUTCH ASSY

GEAR (REEL) SW BOARD WASHER (G) SCREW (G)

285 286 M691 PM691

3-938-925-01 3-938-922-01 X-3374-291-1 1-454-806-11

GEAR (IDL) GEAR (CAM) MOTOR ASSY SOLENOID, PLUNGER

— 69 —

Remarks

BATTERY (L) CD MOTOR

BATTERY (S)

SECTION 9 ELECTRICAL PARTS LIST

CONTROL

NOTE: •

When indicating parts by reference number, please include the board name. The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.

•


•

•

Abbreviation CND : Canadian IT : Italian

•

Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. -XX, -X mean standardized parts, so they may have some difference from the original one. Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. CAPACITORS: uF: µF

Ref. No.

Part No.

*

1-666-860-11 BATTERY (L) BOARD (US,CND) ***************** 1-666-860-21 BATTERY (L) BOARD (AEP,IT,UK,E) *****************

*

Description

Remarks

3-017-439-01 SPRING (-) (L), BATTERY ************************************************************ 1-666-861-11 BATTERY (S) BOARD (US,CND) ***************** 1-666-861-21 BATTERY (S) BOARD (AEP,IT,UK,E) *****************

* *

3-939-057-01 SPRING (-), BACK UP < CONNECTOR > CN903 1-564-505-11 PLUG, CONNECTOR 2P CN904 1-564-506-11 PLUG, CONNECTOR 3P ************************************************************ 1-639-678-12 CD MOTOR BOARD ****************

*

1-564-722-11 PIN, CONNECTOR (SMALL TYPE) 6P 1-572-085-11 SWITCH, LEAF ************************************************************ A-3321-148-A CONTROL BOARD, COMPLETE (US,CND) ************************* A-3321-186-A CONTROL BOARD, COMPLETE (AEP,IT,UK,E) *************************

* *

3-017-444-01 HOLDER, LCD 3-019-236-01 ILLUMINATOR (LCD) 7-685-535-14 SCREW +BTP 2.6X10 TYPE2 N-S

Ref. No.

•

• •

RESISTORS All resistors are in ohms. METAL: metal-film resistor METAL OXIDE: Metal Oxide-film resistor F: nonflammable COILS uH: µH SEMICONDUCTORS In each case, u: µ, for example: uA...: µA... , uPA... , µPA... , uPB... , µPB... , uPC... , µPC... , uPD..., µPD...

Part No.

Description

C820 C822 C823 C824 C825

1-102-960-00 1-162-294-31 1-162-294-31 1-162-294-31 1-136-165-00

CERAMIC CERAMIC CERAMIC CERAMIC FILM

24PF 0.001uF 0.001uF 0.001uF 0.1uF

5% 10% 10% 10% 5%

Remarks 50V 50V 50V 50V 50V

C826 C827 C828 C829 C830

1-162-294-31 1-162-294-31 1-162-294-31 1-162-294-31 1-162-294-31

CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC

0.001uF 0.001uF 0.001uF 0.001uF 0.001uF

10% 10% 10% 10% 10%

50V 50V 50V 50V 50V

C831 C832 C833 C834 C835

1-162-294-31 1-162-294-31 1-162-294-31 1-162-294-31 1-162-294-31


0.001uF 0.001uF 0.001uF 0.001uF 0.001uF

10% 10% 10% 10% 10%

50V 50V 50V 50V 50V

C836 C837 C838 C839 C841

1-162-294-31 1-162-294-31 1-162-294-31 1-162-294-31 1-162-294-31


0.001uF 0.001uF 0.001uF 0.001uF 0.001uF

10% 10% 10% 10% 10%

50V 50V 50V 50V 50V

C842 C843 C844 C845

1-162-294-31 1-162-294-31 1-162-294-31 1-162-294-31

CERAMIC CERAMIC CERAMIC CERAMIC

0.001uF 0.001uF 0.001uF 0.001uF

10% 10% 10% 10%

C846 C847 C848 C849 C850

1-162-282-31 1-162-282-31 1-162-294-31 1-162-282-31 1-162-306-11


100PF 100PF 0.001uF 100PF 0.01uF

10% 10% 10% 10% 30%

C851

1-162-282-31 CERAMIC

100PF

10%

C852

1-162-306-11 CERAMIC

0.01uF

C853

1-162-282-31 CERAMIC

100PF

< CAPACITOR > C800 C801 C803 C806 C807

1-164-159-21 1-164-159-21 1-162-306-11 1-126-967-11 1-126-964-11

CERAMIC CERAMIC CERAMIC ELECT ELECT

0.1uF 0.1uF 0.01uF 47uF 10uF

30% 20% 20%

50V 50V 16V 10V 50V

C808 C809 C810 C811 C812

1-102-514-11 1-102-516-11 1-162-282-31 1-162-282-31 1-102-960-00


22PF 27PF 100PF 100PF 24PF

5% 5% 10% 10% 5%

50V 50V 50V 50V 50V

C813 C815 C817 C818 C819

1-102-960-00 1-136-165-00 1-162-306-11 1-162-306-11 1-102-960-00

CERAMIC FILM CERAMIC CERAMIC CERAMIC

24PF 0.1uF 0.01uF 0.01uF 24PF

5% 5% 30% 30% 5%

50V 50V 16V 16V 50V

1-691-071-31 1-695-381-31 1-695-388-21 1-564-704-11

HOUSING, CONNECTOR 12P PIN, CONNECTOR (PC BOARD) 20P PIN, CONNECTOR (PC BOARD) 27P PIN, CONNECTOR (SMALL TYPE) 2P < DIODE >

D801 D802 D803 D804

— 70 —

8-719-991-33 8-719-991-33 8-719-991-33 8-719-991-33

DIODE DIODE DIODE DIODE

1SS133T-77 1SS133T-77 1SS133T-77 1SS133T-77

50V 50V 50V 50V 16V

50V (US,CND) 30% 16V (AEP,IT,UK,E) 10% 50V

< CONNECTOR > CN801 * CN802 CN803 * CN804

50V 50V 50V 50V (US,CND)

CONTROL Ref. No.

Part No.

Description

Remarks

Ref. No.

< IC > IC801 IC801 IC803

8-752-890-50 IC CXP83124A-021Q (US,CND) 8-752-894-98 IC CXP83124A-027Q (AEP,IT,UK,E) 8-759-430-16 IC PST600I < COIL >

L803 L804

1-410-509-11 INDUCTOR 1-410-509-11 INDUCTOR

10uH 10uH

Part No.

Description

R837 R838 R839 R840 R841

1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11

CARBON CARBON CARBON CARBON CARBON

R842 R843 R844

H/P Remarks

1K 1K 1K 1K 1K

5% 5% 5% 5% 5%

1-249-417-11 CARBON 1-249-437-11 CARBON 1-249-415-11 CARBON

1K 47K 680

5% 5% 5%

R844

1-249-422-11 CARBON

2.7K

R845

1-249-417-11 CARBON

1K

1/4W F 1/4W 1/4W F (US,CND) 5% 1/4W F (AEP,IT,UK,E) 5% 1/4W F

R846 R847 R848 R849 R850

1-249-425-11 1-247-885-00 1-249-441-11 1-247-883-00 1-247-883-00


4.7K 180K 100K 150K 150K

5% 5% 5% 5% 5%

1/4W F 1/4W 1/4W 1/4W 1/4W

R851 R852 R853 R854 R855

1-249-413-11 1-249-429-11 1-249-417-11 1-249-425-11 1-249-415-11


470 10K 1K 4.7K 680

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R856 R857 R858 R859 R860

1-249-416-11 1-249-418-11 1-249-420-11 1-247-843-11 1-249-427-11


820 1.2K 1.8K 3.3K 6.8K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R861 R890 R891 R894 R896

1-249-432-11 1-249-417-11 1-249-437-11 1-247-843-11 1-247-887-00


18K 1K 47K 3.3K 220K

5% 5% 5% 5% 5%

1/4W 1/4W F 1/4W 1/4W 1/4W

R897

1-247-895-91 CARBON

470K

5%

1/4W

< LIQUID CRYSTAL DISPLAY >

1/4W 1/4W 1/4W 1/4W 1/4W

F F F F F

LCD801 1-801-874-11 DISPLAY PANEL, LIQUID CRYSTAL < PILOT LAMP > PL801 PL802

1-517-487-11 LAMP, PILOT 1-517-487-11 LAMP, PILOT < TRANSISTOR >

Q803 Q804 Q805

8-729-922-66 TRANSISTOR 2SC2410SN 8-729-922-66 TRANSISTOR 2SC2410SN 8-729-029-49 TRANSISTOR DTA143TSA-TP < RESISTOR >

R801 R803 R804 R805 R806

1-249-417-11 1-247-807-31 1-249-417-11 1-249-417-11 1-249-417-11


1K 100 1K 1K 1K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

F

R807 R808 R809 R810 R811

1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11


1K 1K 1K 1K 1K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

F F F F F

R812 R813 R814 R815 R816

1-247-807-31 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11


100 1K 1K 1K 1K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

F F F F

R817 R818 R819 R820 R821

1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11


1K 1K 1K 1K 1K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

F F F F F

R822 R823 R824 R825 R826

1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11


1K 1K 1K 1K 1K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

F F F F F

R827 R828 R829 R830 R831

1-249-417-11 1-249-417-11 1-249-426-11 1-249-417-11 1-249-417-11


1K 1K 5.6K 1K 1K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

F F

R832 R833 R834 R835 R836

1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11


1K 1K 1K 1K 1K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

F F F F F

F F F

F F F F F F F F

< SWITCH > S801 S802 S803 S804 S805

1-554-088-00 1-554-088-00 1-554-088-00 1-554-088-00 1-554-088-00

SWITCH, KEY BOARD (STBY) SWITCH, KEY BOARD (SLEEP) SWITCH, KEY BOARD (CLOCK) SWITCH, KEY BOARD (PGM SET AUTI PRESET) SWITCH, KEY BOARD (PLAY MODE MONO/ST)

S806 S807 S808

1-554-088-00 SWITCH, KEY BOARD (CANCEL) 1-554-088-00 SWITCH, KEY BOARD (SOUND) 1-554-088-00 SWITCH, KEY BOARD (MEGABASS) < VIBRATOR >

X801 1-767-184-11 VIBRATOR, CERAMIC (4.21MHz) X802 1-567-098-41 VIBRATOR, CRYSTAL (32.768kHz) ************************************************************ * *

F F

1-666-856-11 H/P BOARD (US,CND) ********** 1-666-856-21 H/P BOARD (AEP,IT,UK,E) ********** 3-831-441-99 CUSHION, SPEAKER < CONNECTOR >

* CN305 * CN306

— 71 —

1-564-507-11 PLUG, CONNECTOR 4P 1-564-519-11 PLUG, CONNECTOR 4P

H/P Ref. No.

LAMP Part No.

MAIN Description

Remarks

< JACK > J301

1-566-891-11 JACK (H/P JACK) < COIL >

L101 L201 L304

1-410-314-11 INDUCTOR 1-410-314-11 INDUCTOR 1-410-314-11 INDUCTOR

0.47uH 0.47uH 0.47uH

< RESISTOR > R170 1-249-407-11 CARBON 150 5% 1/4W F R270 1-249-407-11 CARBON 150 5% 1/4W F ************************************************************* 1-667-132-11 LAMP BOARD (US,CND) ************ 1-667-132-21 LAMP BOARD (AEP,IT,UK,E) ************

* *

< PILOT LAMP > PL801 1-517-487-11 LAMP, PILOT PL802 1-517-487-11 LAMP, PILOT ************************************************************* A-3293-850-A MAIN BOARD, COMPLETE (US,CND) ********************* A-3293-877-A MAIN BOARD, COMPLETE (AEP,IT,UK,E) *********************

* *

1-782-627-11 1-782-628-11 1-782-629-11 1-782-630-11 7-685-646-79

WIRE, PARALLEL (FFC) (27 CORE) WIRE, PARALLEL (FFC) (20 CORE) WIRE, PARALLEL (FFC) (14 CORE) WIRE, PARALLEL (FFC) (13 CORE) SCREW +BVTP 3X8 TYPE2 IT-3 < CAPACITOR >

C101 C107 C109 C110 C111

1-162-215-31 1-126-963-11 1-162-215-31 1-126-960-11 1-161-061-11

CERAMIC ELECT CERAMIC ELECT CERAMIC

47PF 4.7uF 47PF 1uF 0.068uF

5% 20% 5% 20% 10%

50V 50V 50V 50V 50V

C112 C113 C114 C115 C118

1-161-061-11 1-162-837-11 1-126-964-11 1-161-055-00 1-126-927-11

CERAMIC CERAMIC ELECT CERAMIC ELECT

0.068uF 0.0068uF 10uF 0.022uF 2200uF

10% 10% 20% 10% 20%

50V 16V 50V 50V 10V

C119 C120 C121 C126 C132

1-136-165-00 1-126-960-11 1-126-967-11 1-136-153-00 1-126-960-11

FILM ELECT ELECT FILM ELECT

0.1uF 1uF 47uF 0.01uF 1uF

5% 20% 20% 5% 20%

50V 50V 10V 50V 50V

C134 C135 C201 C207 C209

1-126-933-11 1-162-286-21 1-162-215-31 1-126-963-11 1-162-215-31

ELECT CERAMIC CERAMIC ELECT CERAMIC

100uF 220PF 47PF 4.7uF 47PF

20% 10% 5% 20% 5%

10V 50V 50V 50V 50V

C210 C211 C212 C213 C214

1-126-960-11 1-161-061-11 1-161-061-11 1-162-837-11 1-126-964-11

ELECT CERAMIC CERAMIC CERAMIC ELECT

1uF 0.068uF 0.068uF 0.0068uF 10uF

20% 10% 10% 10% 20%

50V 50V 50V 16V 50V

Ref. No.

Part No.

Description

C215 C218 C219 C220 C221

1-161-055-00 1-126-927-11 1-136-165-00 1-126-960-11 1-126-967-11

CERAMIC ELECT FILM ELECT ELECT

0.022uF 2200uF 0.1uF 1uF 47uF

10% 20% 5% 20% 20%

50V 10V 50V 50V 10V

C226 C232 C234 C235 C302

1-136-153-00 1-126-960-11 1-126-933-11 1-162-286-21 1-126-967-11

FILM ELECT ELECT CERAMIC ELECT

0.01uF 1uF 100uF 220PF 47uF

5% 20% 20% 10% 20%

50V 50V 10V 50V 10V

C310 C311 C312 C313 C314

1-161-055-00 1-126-933-11 1-126-967-11 1-126-967-11 1-126-933-11

CERAMIC ELECT ELECT ELECT ELECT

0.022uF 100uF 47uF 47uF 100uF

10% 20% 20% 20% 20%

50V 10V 10V 10V 10V

C315 C316 C318 C319 C320

1-126-967-11 1-126-933-11 1-126-934-11 1-126-963-11 1-128-551-11

ELECT ELECT ELECT ELECT ELECT

47uF 100uF 220uF 4.7uF 22uF

20% 20% 20% 20% 20%

10V 10V 10V 50V 25V

C321 C322 C323 C325 C326

1-162-851-11 1-162-851-11 1-126-963-11 1-126-933-11 1-162-306-11

CERAMIC CERAMIC ELECT ELECT CERAMIC

0.1uF 0.1uF 4.7uF 100uF 0.01uF

10% 10% 20% 20% 30%

16V 16V 50V 10V 16V

C327 C330 C331 C332 C333

1-126-934-11 1-162-294-31 1-162-292-31 1-161-055-00 1-124-252-00

ELECT CERAMIC CERAMIC CERAMIC ELECT

220uF 0.001uF 680PF 0.022uF 0.33uF

20% 10% 10% 10% 20%

10V 50V 50V 50V 50V

C334 C335 C336 C337 C338

1-126-963-11 1-126-962-11 1-126-961-11 1-126-964-11 1-126-934-11


4.7uF 3.3uF 2.2uF 10uF 220uF

20% 20% 20% 20% 20%

50V 50V 50V 50V 10V

C339 C342 C345 C346 C347

1-128-551-11 1-104-666-11 1-130-499-00 1-126-959-11 1-161-055-00

ELECT ELECT MYLAR ELECT CERAMIC

22uF 220uF 0.22uF 0.47uF 0.022uF

20% 20% 5% 20% 10%

25V 25V 50V 50V 50V

C348 C349 C350 C351 C352

1-161-055-00 1-126-967-11 1-126-933-11 1-162-851-11 1-136-153-00

CERAMIC ELECT ELECT CERAMIC FILM

0.022uF 47uF 100uF 0.1uF 0.01uF

10% 20% 20% 10% 5%

50V 10V 10V 16V 50V

C362 C399 C700 C701 C702

1-126-960-11 1-136-165-00 1-162-302-11 1-136-153-00 1-162-851-11

ELECT FILM CERAMIC FILM CERAMIC

1uF 0.1uF 0.0022uF 0.01uF 0.1uF

20% 5% 30% 5% 10%

50V 50V 16V 50V 16V

C703 C704 C705 C706 C707

1-162-851-11 1-126-963-11 1-130-489-00 1-130-486-00 1-162-199-31

CERAMIC ELECT MYLAR MYLAR CERAMIC

0.1uF 4.7uF 0.033uF 0.018uF 10PF

10% 20% 5% 10% 5%

16V 50V 50V 50V 50V

C708 C709 C710 C711 C712

1-126-962-11 1-130-493-00 1-162-215-31 1-130-489-00 1-162-306-11

ELECT MYLAR CERAMIC MYLAR CERAMIC

3.3uF 0.068uF 47PF 0.033uF 0.01uF

20% 5% 5% 5% 30%

50V 50V 50V 50V 16V

— 72 —

Remarks

MAIN Ref. No.

Part No.

Description

C713 C714 C715 C716 C717

1-136-153-00 1-130-493-00 1-126-960-11 1-162-199-31 1-126-967-11

FILM MYLAR ELECT CERAMIC ELECT

0.01uF 0.068uF 1uF 10PF 47uF

5% 5% 20% 5% 20%

50V 50V 50V 50V 10V

Remarks

C718 C719 C720 C721 C722

1-162-294-31 1-130-491-00 1-162-305-11 1-101-005-00 1-162-306-11

CERAMIC MYLAR CERAMIC CERAMIC CERAMIC

0.001uF 0.047uF 0.0068uF 22000PF 0.01uF

10% 5% 30%

50V 50V 16V 50V 16V

C723 C724 C725 C726 C727

1-162-600-11 1-162-851-11 1-101-005-00 1-126-964-11 1-162-306-11

CERAMIC CERAMIC CERAMIC ELECT CERAMIC

0.0047uF 0.1uF 22000PF 10uF 0.01uF

30% 10% 20% 30%

16V 16V 50V 50V 16V

C728 C729 C730 C731 C732

1-126-934-11 1-162-306-11 1-126-967-11 1-136-153-00 1-126-967-11

ELECT CERAMIC ELECT FILM ELECT

220uF 0.01uF 47uF 0.01uF 47uF

20% 30% 20% 5% 20%

10V 16V 10V 50V 10V

C733 C734 C735 C736 C737

1-126-959-11 1-162-306-11 1-162-290-31 1-162-286-21 1-162-306-11

ELECT CERAMIC CERAMIC CERAMIC CERAMIC

0.47uF 0.01uF 470PF 220PF 0.01uF

20% 30% 10% 10% 30%

50V 16V 50V 50V 16V

C738 C739 C740 C742 C743

1-130-499-00 1-162-306-11 1-162-302-11 1-162-199-31 1-162-199-31

MYLAR CERAMIC CERAMIC CERAMIC CERAMIC

0.22uF 0.01uF 0.0022uF 10PF 10PF

5% 30% 30% 5% 5%

50V 16V 16V 50V 50V

C745 C747 C748 C749 C750

1-162-302-11 1-126-964-11 1-162-851-11 1-126-967-11 1-126-924-11

CERAMIC ELECT CERAMIC ELECT ELECT

0.0022uF 10uF 0.1uF 47uF 330uF

30% 20% 10% 20% 20%

16V 50V 16V 10V 10V

C751 C752 C753 C755 C760

1-136-153-00 1-162-306-11 1-126-935-11 1-162-294-31 1-126-963-11

FILM CERAMIC ELECT CERAMIC ELECT

0.01uF 0.01uF 470uF 0.001uF 4.7uF

5% 30% 20% 10% 20%

50V 16V 16V 50V 50V

C761 C762 C763 C770 C771

1-162-290-31 1-162-290-31 1-162-306-11 1-126-963-11 1-162-294-31

CERAMIC CERAMIC CERAMIC ELECT CERAMIC

470PF 470PF 0.01uF 4.7uF 0.001uF

10% 10% 30% 20% 10%

50V 50V 16V 50V 50V

C772 C773 C797 C798 C799

1-162-306-11 1-162-851-11 1-162-306-11 1-162-294-31 1-162-294-31


0.01uF 0.1uF 0.01uF 0.001uF 0.001uF

30% 10% 30% 10% 10%

16V 16V 16V 50V 50V

30%

< CONNECTOR > * CN301 * CN302 CN303 CN304 CN701

1-695-337-31 1-695-381-31 1-695-388-21 1-695-336-31 1-774-975-11

PIN, CONNECTOR (PC BOARD) 14P PIN, CONNECTOR (PC BOARD) 20P PIN, CONNECTOR (PC BOARD) 27P PIN, CONNECTOR (PC BOARD) 13P CONNECTOR, FFC/FPC 16P

Ref. No.

Part No.

Description

Remarks

< DIODE > D301 D302 D303 D304 D306

8-719-991-33 8-719-991-33 8-719-991-33 8-719-991-33 8-719-991-33

DIODE DIODE DIODE DIODE DIODE

1SS133T-77 1SS133T-77 1SS133T-77 1SS133T-77 1SS133T-77

D310 D311 D313 D314 D361

8-719-109-89 8-719-991-33 8-719-991-33 8-719-991-33 8-719-991-33


RD5.6ESB2 1SS133T-77 1SS133T-77 1SS133T-77 1SS133T-77

D702

8-719-991-33 DIODE 1SS133T-77 < FERRITE BEAD >

FB701 FB702 FB703 FB704 FB705

1-410-397-21 1-410-397-21 1-410-397-21 1-410-397-21 1-410-397-21

FERRITE BEAD INDUCTOR FERRITE BEAD INDUCTOR FERRITE BEAD INDUCTOR FERRITE BEAD INDUCTOR FERRITE BEAD INDUCTOR < IC >

IC302 IC303 IC304 IC305 IC309

8-759-432-41 8-759-800-71 8-759-820-22 8-759-076-15 8-759-479-70

IC IC IC IC IC

BH3854AS LA2010 LA4597 KIA4558P S-81250SGY-Z

IC701 IC702 IC703

8-752-082-14 IC CXA1992BR 8-752-380-64 IC CXD2529Q 8-759-478-60 IC BA6898S < COIL >

L301 L302 L303 L701

1-410-509-11 1-410-509-11 1-410-509-11 1-412-852-11

INDUCTOR INDUCTOR INDUCTOR INDUCTOR

10uH 10uH 10uH 47uH

< TRANSISTOR > Q101 Q101 Q103 Q104 Q105

8-729-115-80 8-729-029-72 8-729-905-50 8-729-905-50 8-729-905-50

TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR

BA1A4P DTC114YS-TP DTC343TS DTC343TS DTC343TS

Q106 Q107 Q201 Q203 Q204

8-729-905-50 8-729-905-50 8-729-115-80 8-729-905-50 8-729-905-50


DTC343TS DTC343TS BA1A4P DTC343TS DTC343TS

Q205 Q206 Q207 Q301 Q311

8-729-905-50 8-729-905-50 8-729-905-50 8-729-115-80 8-729-036-86


DTC343TS DTC343TS DTC343TS BA1A4P KTC3203Y-AT

Q312 Q312 Q313 Q314 Q315

8-729-115-82 8-729-030-10 8-729-920-94 8-729-115-80 8-729-036-86


BA1L4L-TP DTC144WS-TP DTA123YS BA1A4P KTC3203Y-AT

— 73 —

MAIN Ref. No.

Part No.

Description

Part No.

Description

Q316 Q316 Q317 Q318 Q319

8-729-037-34 8-729-902-80 8-729-036-89 8-729-801-84 8-729-115-80


KRA107M DTA114YS KTC3198GR-AT 2SB1013-4 BA1A4P

Remarks

R212 R213 R214 R215 R216

1-249-427-11 1-249-419-11 1-249-417-11 1-249-417-11 1-249-441-11


6.8K 1.5K 1K 1K 100K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

Q320 Q321 Q321 Q322 Q322

8-729-115-80 8-729-037-34 8-729-902-80 8-729-037-34 8-729-902-80


BA1A4P KRA107M DTA114YS KRA107M DTA114YS

R217 R218 R219 R220 R223

1-249-435-11 1-249-429-11 1-249-429-11 1-249-420-11 1-249-401-11


33K 10K 10K 1.8K 47

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W F 1/4W F

Q323 Q323 Q324 Q325 Q326

8-729-037-34 8-729-902-80 8-729-036-89 8-729-036-89 8-729-037-34


KRA107M DTA114YS KTC3198GR-AT KTC3198GR-AT KRA107M

R224 R225 R231 R232 R233

1-249-387-11 1-249-421-11 1-249-431-11 1-247-843-11 1-249-437-11


3.3 2.2K 15K 3.3K 47K

5% 5% 5% 5% 5%

1/4W F 1/4W F 1/4W 1/4W 1/4W

Q326 Q327 Q328 Q329 Q329

8-729-902-80 8-729-036-89 8-729-115-80 8-729-037-34 8-729-902-80


DTA114YS KTC3198GR-AT BA1A4P KRA107M DTA114YS

R234 R301

1-249-425-11 CARBON 1-247-807-31 CARBON

4.7K 100

5% 5%

R301

1-249-417-11 CARBON

1K

Q361 Q362 Q363 Q365 Q701

8-729-115-80 8-729-801-84 8-729-115-80 8-729-036-86 8-729-037-02


BA1A4P 2SB1013-4 BA1A4P KTC3203Y-AT KTA1266Y-AT

R313 R314

1-249-426-11 CARBON 1-247-891-00 CARBON

5.6K 330K

1/4W F 1/4W (US,CND) 5% 1/4W F (AEP,IT,UK,E) 5% 1/4W 5% 1/4W

R315 R316 R317 R318 R319

1-249-441-11 1-249-429-11 1-249-430-11 1-247-903-00 1-247-903-00


100K 10K 12K 1M 1M

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

< RESISTOR >

Ref. No.

Remarks F F F F

R101 R102 R107 R108 R109

1-249-417-11 1-249-431-11 1-247-843-11 1-249-429-11 1-249-426-11


1K 15K 3.3K 10K 5.6K

5% 5% 5% 5% 5%

1/4W F 1/4W 1/4W 1/4W 1/4W

R320 R321 R323 R324 R325

1-249-441-11 1-249-432-11 1-249-401-11 1-249-429-11 1-249-429-11


100K 18K 47 10K 10K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W F 1/4W 1/4W

R110 R111 R112 R113 R114

1-249-425-11 1-249-401-11 1-249-427-11 1-249-419-11 1-249-417-11


4.7K 47 6.8K 1.5K 1K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

F F F F F

R326 R327 R328 R329 R330

1-249-429-11 1-249-421-11 1-247-843-11 1-247-903-00 1-249-429-11


10K 2.2K 3.3K 1M 10K

5% 5% 5% 5% 5%

1/4W 1/4W F 1/4W 1/4W 1/4W

R115 R116 R117 R118 R119

1-249-417-11 1-249-441-11 1-249-435-11 1-249-429-11 1-249-429-11


1K 100K 33K 10K 10K

5% 5% 5% 5% 5%

1/4W F 1/4W 1/4W 1/4W 1/4W

R331 R332 R334 R335 R336

1-249-429-11 1-249-425-11 1-249-429-11 1-249-407-11 1-247-895-91


10K 4.7K 10K 150 470K

5% 5% 5% 5% 5%

1/4W 1/4W F 1/4W 1/4W F 1/4W

R120 R123 R124 R125 R131

1-249-420-11 1-249-401-11 1-249-387-11 1-249-421-11 1-249-431-11


1.8K 47 3.3 2.2K 15K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

F F F F

R337 R338 R340 R341 R342

1-249-437-11 1-249-429-11 1-249-425-11 1-249-418-11 1-247-903-00


47K 10K 4.7K 1.2K 1M

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W F 1/4W F 1/4W

R132 R133 R134 R201 R202

1-247-843-11 1-249-437-11 1-249-425-11 1-249-417-11 1-249-431-11


3.3K 47K 4.7K 1K 15K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W F 1/4W F 1/4W

R344 R345 R346 R350 R361

1-249-401-11 1-249-425-11 1-249-429-11 1-249-441-11 1-249-417-11


47 4.7K 10K 100K 1K

5% 5% 5% 5% 5%

1/4W F 1/4W F 1/4W 1/4W 1/4W F

R207 R208 R209 R210 R211

1-247-843-11 1-249-429-11 1-249-426-11 1-249-425-11 1-249-401-11


3.3K 10K 5.6K 4.7K 47

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W F 1/4W F

R362 R363 R364 R365 R366

1-249-441-11 1-249-441-11 1-249-441-11 1-249-441-11 1-249-435-11


100K 100K 100K 100K 33K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

— 74 —

MAIN Ref. No.

POWER

Part No.

Description

Remarks

Ref. No.

Part No.

R367 R368 R369 R370 R371

1-249-441-11 1-249-441-11 1-249-417-11 1-249-413-11 1-249-441-11


100K 100K 1K 470 100K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W F 1/4W F 1/4W

*

A-3321-150-A POWER BOARD, COMPLETE (US,CND) *********************** A-3293-875-A POWER BOARD, COMPLETE (AEP,IT,UK,E) ***********************

R377 R700 R701 R702 R703

1-249-437-11 1-249-429-11 1-247-843-11 1-247-899-11 1-249-441-11


47K 10K 3.3K 680K 100K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R704 R705 R706 R707 R708

1-247-896-11 1-249-439-11 1-249-441-11 1-249-437-11 1-249-441-11


510K 68K 100K 47K 100K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R709 R710 R711 R712 R713

1-249-432-11 1-247-887-00 1-249-435-11 1-249-430-11 1-249-429-11


18K 220K 33K 12K 10K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R714 R716 R718 R719 R720

1-247-903-00 1-249-411-11 1-249-393-11 1-249-441-11 1-249-441-11


1M 330 10 100K 100K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W F 1/4W 1/4W

R721 R722 R723 R724 R725

1-249-441-11 1-249-441-11 1-249-440-11 1-249-440-11 1-247-891-00


100K 100K 82K 82K 330K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R726 R727 R728 R731 R732

1-247-883-00 1-247-883-00 1-247-887-00 1-249-437-11 1-249-437-11


150K 150K 220K 47K 47K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R733 R734 R735 R736 R737

1-247-843-11 1-249-417-11 1-249-429-11 1-247-903-00 1-249-429-11


3.3K 1K 10K 1M 10K

5% 5% 5% 5% 5%

1/4W 1/4W F 1/4W 1/4W 1/4W

R738 R739 R740 R745 R746

1-247-887-00 1-249-417-11 1-249-417-11 1-249-417-11 1-249-435-11


220K 1K 1K 1K 33K

5% 5% 5% 5% 5%

1/4W 1/4W F 1/4W F 1/4W F 1/4W

R747 R748 R749 R750 R751

1-247-863-91 1-249-437-11 1-247-843-11 1-249-417-11 1-249-430-11


22K 47K 3.3K 1K 12K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W F 1/4W

R752 R754 R799


7.5K 47K 10K

5% 5% 5%

1/4W 1/4W 1/4W

*

Description

Remarks

1-533-233-21 HOLDER, FUSE 7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3 < CAPACITOR > C900 C901 C902 C903 C904

1-128-548-11 1-101-005-00 1-101-005-00 1-101-005-00 1-101-005-00

C905


4700uF 22000PF 22000PF 22000PF 22000PF

20%

25V 50V 50V 50V 50V

1-136-165-00 FILM

0.1uF

5%

C906 C907 C908 C909

1-161-055-00 1-161-055-00 1-126-967-11 1-126-934-11

CERAMIC CERAMIC ELECT ELECT

0.022uF 0.022uF 47uF 220uF

50V (AEP,IT,UK,E) 10% 50V 10% 50V 20% 10V 20% 10V

C910 C911 C912 C913

1-161-055-00 1-161-055-00 1-126-934-11 1-126-933-11

CERAMIC CERAMIC ELECT ELECT

0.022uF 0.022uF 220uF 100uF

10% 10% 20% 20%

50V 50V 10V 10V

< CONNECTOR > CN901

1-564-510-11 PLUG, CONNECTOR 7P < DIODE >

D901 D902 D903 D904 D905

8-719-046-07 8-719-046-07 8-719-046-07 8-719-046-07 8-719-991-33


2A02M 2A02M 2A02M 2A02M 1SS133T-77

D906 D907 D908 D909 D910

8-719-991-33 8-719-981-95 8-719-110-14 8-719-110-09 8-719-991-33


1SS133T-77 MTZJ-2.7B RD9.1ES-B3 RD8.2ES-B3 1SS133T-77

D911

8-719-991-33 DIODE 1SS133T-77 < FUSE >

! F901 ! F901

1-532-505-31 FUSE (5A 250V) (AEP,IT,UK,E) 1-533-420-11 FUSE ,GLASS CYLINDRICAL (DIA.5) (5A 125V) (US, CND) < JACK >

! J901 ! J901

1-540-009-11 INLET, AC (⁄ AC IN) (US,CND) 1-526-838-11 INLET, AC 2P (⁄ AC IN) (AEP,IT,UK,E) < TRANSISTOR >

Q901 Q902

8-729-209-15 TRANSISTOR 2SD2012 8-729-209-15 TRANSISTOR 2SD2012

< VIBRATOR > X701 1-767-226-11 VIBRATOR, CRYSTAL (16.9344NHz) *************************************************************

— 75 —



POWER Ref. No.

RETAINER

Part No.

SW

SWITCH

Description

Remarks

Ref. No.

Part No.

< RESISTOR > ! R901 1-211-757-11 FUSIBLE 1 5% 1/2W F ! R902 1-211-757-11 FUSIBLE 1 5% 1/2W F R903 1-249-410-11 CARBON 270 5% 1/4W F R904 1-249-414-11 CARBON 560 5% 1/4W F R905 1-249-421-11 CARBON 2.2K 5% 1/4W F ************************************************************* 1-666-862-11 RETAINER BOARD (US,CND) *************** 1-666-862-21 RETAINER BOARD (AEP,IT,UK,E) ***************

* *

************************************************************* 1-662-742-11 SW BOARD ********

*

< CONNECTOR > CN691

Description

Remarks

< IC >

1-580-170-11 PIN,CONNECTOR (PC BOARD) 9P

IC802

8-742-012-11 HY B IC SBX1976-51 < RESISTOR >

R862 R863 R864 R865 R866

1-249-425-11 1-249-415-11 1-249-416-11 1-249-418-11 1-249-420-11


4.7K 680 820 1.2K 1.8K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

F F F F F

R867 R869 R870 R871 R872

1-247-843-11 1-249-427-11 1-249-432-11 1-249-425-11 1-249-415-11


3.3K 6.8K 18K 4.7K 680

5% 5% 5% 5% 5%

1/4W 1/4W F 1/4W 1/4W F 1/4W F

R873 R874 R875 R876 R877

1-249-416-11 1-249-418-11 1-249-420-11 1-247-843-11 1-249-427-11


820 1.2K 1.8K 3.3K 6.8K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R878 R879 R880 R881 R882

1-249-432-11 1-249-425-11 1-249-415-11 1-249-416-11 1-249-418-11


18K 4.7K 680 820 1.2K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R883 R884 R885 R886 R887

1-249-420-11 1-247-843-11 1-249-427-11 1-249-410-11 1-249-432-11


1.8K 3.3K 6.8K 270 18K

5% 5% 5% 5% 5%

1/4W F 1/4W 1/4W F 1/4W F 1/4W

R893 R895

1-249-407-11 CARBON 1-249-407-11 CARBON

150 150

5% 5%

1/4W F 1/4W F

F F F F

< PHOTO INTERUPTER > PH691

1-801-455-11 PHOTO REFLECTOR < PLUNGER SOLENOID >

PM691

1-454-806-11 SOLENOID, PLUNGER < RESISTOR >

R691

F F F F

1-247-822-11 RES,CARBON (SMALL) 430 < SWITCH >

S691 1-762-811-11 SWITCH,LEAF (HALF) S692 1-762-811-11 SWITCH,LEAF (CrO2) S694 1-762-811-11 SWITCH,LEAF (ERASE PROOF A) S695 1-762-811-11 SWITCH,LEAF (ERASE PROOF B) S696 1-762-810-11 SWITCH,LEAF (HEAD POSITION) ************************************************************* A-3321-154-A SWITCH BOARD, COMPLETE (US,CND,E) *********************** A-3321-191-A SWITCH BOARD, COMPLETE (AEP,IT,UK) ***********************

* *

1-782-632-11 WIRE, PARALLEL (FFC) (12 CORE) < CONNECTOR > * CN805

1-695-373-31 PIN, CONNECTOR (PC BOARD) 12P < DIODE > DIODE DIODE DIODE DIODE DIODE

SLR-342MGTC7 (CD ^) SLR-342MGTC7 (CD p) SLR-342MGTC7 (RADIO BOARD) SLR-342MGTC7 (PRESET(+)) SLR-342MGTC7 (TAPE p)

D805 D806 D807 D808 D809

8-719-067-05 8-719-067-05 8-719-067-05 8-719-067-05 8-719-067-05

D810 D811

8-719-067-05 DIODE SLR-342MGTC7 (TAPE ”) 8-719-058-48 DIODE SLR-342VRTH7 (OPR/BATT)

< SWITCH > S809 S810 S811 S812 S813

1-692-014-11 1-692-014-11 1-692-014-11 1-692-014-11 1-692-014-11

SWITCH, KEY BOARD (POWER) SWITCH, KEY BOARD (TMER) SWITCH, KEY BOARD (CD ^) SWITCH, KEY BOARD (CD p) SWITCH, KEY BOARD (DISPLAY/ENTER)

S814 S815 S816 S817 S818

1-692-014-11 1-692-014-11 1-692-014-11 1-692-014-11 1-692-014-11

SWITCH, KEY BOARD (EDIT) SWITCH, KEY BOARD (VOL(–)) SWITCH, KEY BOARD (VOL(+)) SWITCH, KEY BOARD (RADIO BAND) SWITCH, KEY BOARD (PRESET(–))

S819 S820 S821 S822 S823

1-692-014-11 1-692-014-11 1-692-014-11 1-692-014-11 1-692-014-11

SWITCH, KEY BOARD (PRESET(+)) SWITCH, KEY BOARD (TUNER(–)) SWITCH, KEY BOARD (TUNER(+)) SWITCH, KEY BOARD (TC-AMS(+)) SWITCH, KEY BOARD (TC-AMS(–))

S825 S826 S827 S828 S829

1-692-014-11 1-692-014-11 1-692-014-11 1-692-014-11 1-692-014-11

SWITCH, KEY BOARD (TAPE ”) SWITCH, KEY BOARD (TAPE “) SWITCH, KEY BOARD (TAPE p) SWITCH, KEY BOARD (r/P) SWITCH, KEY BOARD (DIR/MODE)

S830 1-692-014-11 SWITCH, KEY BOARD (COUNTER RESET) *************************************************************

— 76 —



TC Ref. No.

Part No.

*

A-3293-842-A TC BOARD, COMPLETE (US,CND) ******************* A-3293-869-A TC BOARD, COMPLETE (AEP,IT,UK,E) *******************

*

Description

Remarks

Ref. No.

Part No.

Description

Remarks

< DIODE > D401 D402 D403

8-719-991-33 DIODE 1SS133T-77 8-719-991-33 DIODE 1SS133T-77 8-719-991-33 DIODE 1SS133T-77

< CAPACITOR > < IC > C401

1-130-481-00 MYLAR

0.0068uF 5%

C401

1-130-482-00 MYLAR

0.0082uF 5%

C402

1-130-469-00 MYLAR

680PF

5%

C402

1-130-471-00 MYLAR

0.001uF

5%

C403

1-130-471-00 MYLAR

0.001uF

5%

C404 C405 C406 C407 C408

1-126-967-11 1-162-306-11 1-130-481-00 1-130-479-00 1-162-306-11

47uF 0.01uF 0.0068uF 0.0047uF 0.01uF

20% 30% 5% 5% 30%

10V 16V 50V 50V 16V (US,CND)

C409

1-162-306-11 CERAMIC

0.01uF

30%

C410 C411 C412 C413

1-126-963-11 1-126-934-11 1-126-967-11 1-161-020-11

ELECT ELECT ELECT CERAMIC

4.7uF 220uF 47uF 0.039uF

20% 20% 20% 10%

16V (US,CND) 50V 10V 10V 25V

C414 C415 C416 C417 C418

1-126-964-11 1-126-966-11 1-126-964-11 1-126-967-11 1-126-967-11


10uF 33uF 10uF 47uF 47uF

20% 20% 20% 20% 20%

C419

1-126-967-11 ELECT

47uF

20%

C420

1-126-967-11 ELECT

C499 C501 C502

1-136-165-00 FILM 1-162-301-11 CERAMIC 1-126-967-11 ELECT

10V (AEP,IT,UK,E) 47uF 20% 10V (AEP,IT,UK,E) 0.1uF 5% 50V 0.0015uF 20% 16V 47uF 20% 10V

C503 C504 C505 C506 C508

1-161-020-11 1-162-301-11 1-126-963-11 1-126-959-11 1-126-963-11

CERAMIC CERAMIC ELECT ELECT ELECT

0.039uF 0.0015uF 4.7uF 0.47uF 4.7uF

10% 30% 20% 20% 20%

C509 C510 C601 C602 C603

1-126-964-11 1-162-282-31 1-162-301-11 1-126-967-11 1-161-020-11

ELECT CERAMIC CERAMIC ELECT CERAMIC

10uF 100PF 0.0015uF 47uF 0.039uF

C604 C605 C606 C608 C609

1-162-301-11 1-126-963-11 1-126-959-11 1-126-963-11 1-126-964-11

CERAMIC ELECT ELECT ELECT ELECT

C610

1-162-282-31 CERAMIC

ELECT CERAMIC MYLAR MYLAR CERAMIC

50V (AEP,IT,UK,E) 50V (US,CND) 50V (US,CND) 50V (AEP,IT,UK,E) 50V

8-759-264-71 IC TA2068N < COIL >

L501 L502 L601 L602

1-414-146-31 1-414-146-31 1-414-146-31 1-414-146-31

INDUCTOR INDUCTOR INDUCTOR INDUCTOR

2.2uH 2.2uH 2.2uH 2.2uH

< TRANSISTOR > Q401 Q402 Q403 Q405 Q406

8-729-036-80 8-729-036-80 8-729-036-86 8-729-115-80 8-729-115-80


KRC110M KRC110M KTC3203Y-AT BA1A4P BA1A4P

Q408 Q409 Q410 Q411 Q413

8-729-036-86 8-729-036-86 8-729-037-02 8-729-115-80 8-729-037-02


KTC3203Y-AT KTC3203Y-AT KTA1266Y-AT BA1A4P KTA1266Y-AT

< RESISTOR > R401 R402 R403 R404 R405

1-249-393-11 1-249-401-11 1-249-429-11 1-249-425-11 1-249-393-11


10 47 10K 4.7K 10

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R406 R407 R408 R409 R410

1-249-419-11 1-249-419-11 1-249-441-11 1-247-791-91 1-249-429-11


1.5K 1.5K 100K 22 10K

5% 5% 5% 5% 5%

1/4W F 1/4W F 1/4W 1/4W 1/4W

25V 16V 50V 50V 50V

R411 R412 R413 R414 R416

1-249-429-11 1-247-843-11 1-247-843-11 1-247-843-11 1-247-903-00


10K 3.3K 3.3K 3.3K 1M

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

20% 10% 20% 20% 10%

50V 50V 16V 10V 25V

R417 R418 R419


47K 4.7K 1K

5% 5% 5%

R420

1-249-417-11 CARBON

1K

0.0015uF 4.7uF 0.47uF 4.7uF 10uF

30% 20% 20% 20% 20%

16V 50V 50V 50V 50V

R501

1-249-431-11 CARBON

15K

1/4W 1/4W F 1/4W F (AEP,IT,UK,E) 5% 1/4W F (AEP,IT,UK,E) 5% 1/4W

100PF

10%

50V

R502 R503 R504 R505 R506

1-249-403-11 1-249-440-11 1-247-843-11 1-249-417-11 1-249-417-11


68 82K 3.3K 1K 1K

5% 5% 5% 5% 5%

1/4W F 1/4W 1/4W 1/4W F 1/4W F

R601 R602 R603 R604 R605

1-249-431-11 1-249-403-11 1-249-440-11 1-247-843-11 1-249-417-11


15K 68 82K 3.3K 1K

5% 5% 5% 5% 5%

1/4W 1/4W F 1/4W 1/4W 1/4W F

< CONNECTOR > * CN401 CN402

50V 16V 50V 10V 10V

IC401

1-695-337-31 PIN, CONNECTOR (PC BOARD) 14P 1-564-707-11 PIN, CONNECTOR (SMALL TYPE) 5P

— 77 —

F F F F

TC Ref. No. R606

TERMINAL Part No.

TUNER

Description

1-249-417-11 CARBON

1K

5%

Remarks

Ref. No.

Part No.

Description

1/4W F

C8 C9 C10 C11 C12

1-162-201-31 1-102-821-00 1-162-851-11 1-102-820-00 1-126-964-11

CERAMIC CERAMIC CERAMIC CERAMIC ELECT

12PF 360PF 0.1uF 330PF 10uF

5% 20%

50V 50V 16V 50V 50V

C13 C14 C15 C16 C17

1-162-306-11 1-161-061-11 1-161-024-00 1-161-024-00 1-126-963-11

CERAMIC CERAMIC CERAMIC CERAMIC ELECT

0.01uF 0.068uF 0.082uF 0.082uF 4.7uF

30% 10% 10% 10% 20%

16V 50V 25V 25V 50V

C18 C19 C22 C23 C24

1-126-967-11 1-162-306-11 1-162-306-11 1-161-055-00 1-161-055-00


47uF 0.01uF 0.01uF 0.022uF 0.022uF

20% 30% 30% 10% 10%

16V 16V 16V 50V 50V

C26 C27 C28 C29 C44

1-162-306-11 1-104-666-11 1-126-963-11 1-126-963-11 1-161-051-00

CERAMIC ELECT ELECT ELECT CERAMIC

0.01uF 220uF 4.7uF 4.7uF 0.01uF

30% 20% 20% 20% 10%

16V 25V 50V 50V 50V

C45 C46 C47 C48 C49

1-136-177-00 1-126-964-11 1-162-306-11 1-126-964-11 1-162-306-11

FILM ELECT CERAMIC ELECT CERAMIC

1uF 10uF 0.01uF 10uF 0.01uF

5% 20% 30% 20% 30%

50V 50V 16V 50V 16V

C50 C51 C53 C54 C55

1-162-294-31 1-162-294-31 1-162-294-31 1-102-518-11 1-162-199-31


0.001uF 0.001uF 0.001uF 33PF 10PF

10% 10% 10% 5% 5%

50V 50V 50V 50V 50V

C57 C58 C59 C62 C63

1-162-282-31 1-162-306-11 1-162-306-11 1-162-294-31 1-162-306-11


100PF 0.01uF 0.01uF 0.001uF 0.01uF

10% 30% 30% 10% 30%

50V 16V 16V 50V 16V

C64 C66 C67 C68 C69

1-162-198-31 1-161-051-00 1-162-294-31 1-162-215-31 1-162-306-11


8.2PF 0.01uF 0.001uF 47PF 0.01uF

10% 10% 10% 5% 30%

50V 50V 50V 50V 16V

C71 C72 C73 C74

1-162-294-31 1-162-294-31 1-136-177-00 1-162-306-11

CERAMIC CERAMIC FILM CERAMIC

0.001uF 0.001uF 1uF 0.01uF

10% 10% 5% 30%

50V 50V 50V 16V

< TRANSFORMER > T401 1-433-372-11 TRANSFORMER, BIAS OSCILLATION ************************************************************* 1-666-855-11 TERMINAL BOARD (US,CND) *************** 1-666-855-21 TERMINAL BOARD (AEP,IT,UK,E) ***************

* *

< CAPACITOR > C421 C441 C442

1-162-294-31 CERAMIC 1-126-964-11 ELECT 1-162-851-11 CERAMIC

0.001uF 10uF 0.1uF

10% 20% 10%

50V 50V 16V

< CONNECTOR > CN441 * CN442

1-564-723-11 PIN, CONNECTOR (SMALL TYPE) 7P 1-564-719-11 PIN, CONNECTOR (SMALL TYPE) 3P

Remarks 5% 5%

< DIODE > D441

8-719-067-15 DIODE SLR-342MGTH7 (MD LINE) < FERRITE BEAD >

FB401

1-410-397-21 FERRITE BEAD INDUCTOR < IC >

IC441

8-749-921-12 IC GP1F32T < JACK >

J441 J442

1-566-891-21 JACK (LINE IN) 1-566-891-21 JACK (LINE OUT) < COIL >

L401 L402


10uH 10uH

< RESISTOR > R441

1-249-407-11 CARBON

150

5%

1/4W F

< SWITCH > S441 1-570-940-11 SWITCH, KEY BOARD (MD LINE) *************************************************************

< FILTER > A-3321-151-A TUNER BOARD, COMPLETE (US,CND) **********************

*

CF1 CF2 CF3 CF4

1-533-313-11 HOLDER, FUSE

1-760-127-11 1-760-127-11 1-760-127-11 1-579-762-11

FILTER, CERAMIC FILTER, CERAMIC FILTER, CERAMIC VIBRATOR, CERAMIC

< CAPACITOR > < COMPOSITION CIRCUIT BLOCK > C2 C3 C4 C5 C7

1-162-294-31 1-162-306-11 1-102-514-11 1-162-203-31 1-161-055-00


0.001uF 0.01uF 22PF 15PF 0.022uF

10% 30% 5% 5% 10%

50V 16V 50V 50V 50V

CFT1

1-239-173-11 ENCAPSULATED COMPONENT < CONNECTOR >

* CN1

— 78 —

1-695-374-31 PIN, CONNECTOR (PC BOARD) 13P

TUNER Ref. No.

Part No.

Description

Remarks

Ref. No.

< TRIMMER > CT1 CT2

1-141-411-11 CAP, ADJ 20PF 1-141-411-11 CAP, ADJ 20PF

Part No.

Description

R26 R27 R28 R29 R30

1-249-425-11 1-249-429-11 1-249-437-11 1-249-415-11 1-249-412-11


4.7K 10K 47K 680 390

5% 5% 5% 5% 5%

1/4W F 1/4W 1/4W 1/4W F 1/4W F

Remarks

R35 R35 R37 R38 R39

1-249-417-11 1-249-421-11 1-249-429-11 1-249-421-11 1-249-429-11


1K 2.2K 10K 2.2K 10K

5% 5% 5% 5% 5%

1/4W F 1/4W F 1/4W 1/4W F 1/4W

R40 R41 R42 R43 R46

1-249-429-11 1-249-417-11 1-249-417-11 1-249-437-11 1-249-437-11


10K 1K 1K 47K 47K

5% 5% 5% 5% 5%

1/4W 1/4W F 1/4W F 1/4W 1/4W

R55 R56 R57 R58 R59

1-249-421-11 1-249-407-11 1-249-399-11 1-249-411-11 1-249-437-11


2.2K 150 33 330 47K

5% 5% 5% 5% 5%

1/4W F 1/4W F 1/4W F 1/4W 1/4W

R60 R66

1-249-425-11 CARBON 1-249-437-11 CARBON

4.7K 47K

5% 5%

1/4W F 1/4W

< DIODE > D1 D2 D3 D6 D7

8-719-050-72 8-719-050-72 8-719-050-69 8-719-991-33 8-719-991-33


KV1370NT KV1370NT KV1520N 1SS133T-77 1SS133T-77

< FILTER > FL1

1-236-022-11 FILTER, BAND PASS < IC >

IC1 IC3

8-759-386-02 IC TA2008AN 8-759-290-61 IC BU2615S < JUMPER RESISTOR >

JW22

1-249-421-11 CARBON

2.2K

5%

1/4W F

< COIL > < VIBRATOR > L1 L2 L3 L4 L5

1-409-905-31 1-409-905-31 1-501-762-11 1-411-234-21 1-410-336-11

COIL, FM RF COIL, FM RF ANTENNA, FERRITE-ROD (MW) COIL, AM OSC INDUCTOR 220uH

L7 L8


X1 1-760-130-11 VIBRATOR, CRYSTAL (75kHz) ************************************************************* A-3321-189-A TUNER BOARD, COMPLETE (AEP,IT,UK,E) ***********************

*

220uH 10uH

1-533-313-11 HOLDER, FUSE

< TRANSISTOR > TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR

< CAPACITOR >

Q1 Q2 Q3 Q4 Q15

8-729-115-80 8-729-115-80 8-729-115-80 8-729-115-80 8-729-422-57

BA1A4P BA1A4P BA1A4P BA1A4P UN4111

Q17 Q18 Q19

8-729-012-83 TRANSISTOR 2SK679A 8-729-922-66 TRANSISTOR 2SC2410SN 8-729-106-07 TRANSISTOR 2SK514-H < RESISTOR >

C1 C2 C3 C4 C5

1-162-294-31 1-162-306-11 1-102-960-00 1-162-203-31 1-101-005-00


0.001uF 0.01uF 24PF 15PF 22000PF

C6 C7 C8 C9 C10

1-101-005-00 1-161-055-00 1-162-195-31 1-102-973-00 1-102-823-11


22000PF 0.022uF 4.7PF 100PF 430PF

10% 30% 5% 5%

10% 10% 5% 5%

50V 16V 50V 50V 50V 50V 50V 50V 50V 50V

R1 R2 R3 R4 R5

1-249-441-11 1-247-887-00 1-249-431-11 1-249-429-11 1-249-428-11


100K 220K 15K 10K 8.2

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W F

C11 C12 C14 C15 C16

1-162-199-31 1-136-013-11 1-162-851-11 1-161-494-00 1-126-963-11

CERAMIC FILM CERAMIC CERAMIC ELECT

10PF 360PF 0.1uF 0.022uF 4.7uF

5% 5%

20%

50V 50V 16V 25V 50V

R6 R7 R8 R9 R10

1-247-887-00 1-249-411-11 1-247-863-91 1-249-421-11 1-249-425-11


220K 330 22K 2.2K 4.7K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W F 1/4W F

C17 C18 C19 C20 C21

1-162-288-31 1-162-306-11 1-126-964-11 1-162-849-11 1-162-850-11

CERAMIC CERAMIC ELECT CERAMIC CERAMIC

330PF 0.01uF 10uF 0.068uF 0.082uF

10% 30% 20% 10% 10%

50V 16V 50V 16V 16V

R11 R14 R18 R19 R25

1-247-815-91 1-247-807-31 1-249-417-11 1-249-417-11 1-249-429-11


220 100 1K 1K 10K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W F 1/4W F 1/4W

C22 C23 C24 C25 C26

1-162-850-11 1-161-053-00 1-161-053-00 1-162-306-11 1-162-306-11


0.082uF 0.015uF 0.015uF 0.01uF 0.01uF

10% 10% 10% 30% 30%

16V 50V 50V 16V 16V

— 79 —

TUNER Ref. No.

Part No.

Description

C27 C28 C29 C30 C31

1-126-933-11 1-102-518-11 1-162-199-31 1-162-306-11 1-162-306-11


100uF 33PF 10PF 0.01uF 0.01uF

20% 5% 5% 30% 30%

10V 50V 50V 16V 16V

Remarks

C32 C33 C34 C35 C36

1-162-306-11 1-162-306-11 1-162-294-31 1-162-294-31 1-162-294-31


0.01uF 0.01uF 0.001uF 0.001uF 0.001uF

30% 30% 10% 10% 10%

16V 16V 50V 50V 50V

C37 C38 C39 C40 C41

1-126-964-11 1-162-306-11 1-126-964-11 1-162-306-11 1-136-177-00

ELECT CERAMIC ELECT CERAMIC FILM

10uF 0.01uF 10uF 0.01uF 1uF

20% 30% 20% 30% 5%

50V 16V 50V 16V 50V

C42 C44 C45 C52 C53

1-130-483-00 1-126-963-11 1-126-963-11 1-162-306-11 1-162-306-11

MYLAR ELECT ELECT CERAMIC CERAMIC

0.01uF 4.7uF 4.7uF 0.01uF 0.01uF

5% 20% 20% 30% 30%

50V 50V 50V 16V 16V

C55 C56 C59 C60 C61

1-162-306-11 1-162-306-11 1-162-306-11 1-162-282-31 1-162-306-11


0.01uF 0.01uF 0.01uF 100PF 0.01uF

30% 30% 30% 10% 30%

16V 16V 16V 50V 16V

C63 C64 C67 C68 C69

1-162-294-31 1-162-294-31 1-162-195-31 1-162-306-11 1-162-215-31


0.001uF 0.001uF 4.7PF 0.01uF 47PF

10% 10% 10% 30% 5%

50V 50V 50V 16V 50V

C71 C72 C80 C81

1-126-933-11 1-162-306-11 1-162-294-31 1-162-306-11

ELECT CERAMIC CERAMIC CERAMIC

100uF 0.01uF 0.001uF 0.01uF

20% 30% 10% 30%

16V 16V 50V 16V

Ref. No.

Part No.

Description

Remarks

< DIODE > D1 D2 D3 D4 D5

8-719-991-33 8-719-991-33 8-719-050-72 8-719-050-72 8-719-050-69


1SS133T-77 1SS133T-77 KV1370NT KV1370NT KV1520N

< FILTER > FL1

1-236-022-11 FILTER, BAND PASS < IC >

IC1 IC2

8-759-386-02 IC TA2008AN 8-759-290-61 IC BU2615S < COIL >

L1 L2 L3 L4 L6

1-409-905-11 1-409-904-11 1-501-752-11 1-411-199-31 1-410-336-11

COIL, FM RF COIL, FM OSC ANTENNA, FERRITE-ROD (LW.MW) COIL, MW/LW OSC INDUCTOR 220uH

L7 L11 L20

1-410-521-11 INDUCTOR 1-410-517-11 INDUCTOR 1-410-509-11 INDUCTOR

100uH 47uH 10uH

< TRANSISTOR >

< FILTER > CF1 CF2 CF3 CF4

1-760-468-11 1-760-468-11 1-760-468-11 1-579-762-11

FILTER, CERAMIC FILTER, CERAMIC FILTER, CERAMIC VIBRATOR, CERAMIC

Q1 Q2 Q3 Q4 Q5

8-729-119-32 8-729-922-66 8-729-922-66 8-729-905-50 8-729-178-62


2SK193 2SC2410SN 2SC2410SN DTC343TS 2SC2786-L

Q6 Q9 Q10 Q11 Q12

8-729-922-66 8-729-029-72 8-729-029-72 8-729-029-72 8-729-029-72


2SC2410SN DTC114YS-TP DTC114YS-TP DTC114YS-TP DTC114YS-TP

Q13 Q14 Q15 Q16 Q17

8-729-012-83 8-729-106-07 8-729-029-72 8-729-029-72 8-729-902-80


2SK679A 2SK514-H DTC114YS-TP DTC114YS-TP DTA114YS

Q18 Q21 Q22 Q23

8-729-029-72 8-729-422-57 8-729-422-57 8-729-922-66

TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR

DTC114YS-TP UN4111 UN4111 2SC2410SN

< COMPOSITION CIRCUIT BLOCK > CFT1

1-239-173-11 ENCAPSULATED COMPONENT < CONNECTOR >

* CN1

1-695-374-31 PIN, CONNECTOR (PC BOARD) 13P < TRIMMER >

CT1 CT2 CT3 CT4 CT5

1-141-411-11 1-141-411-11 1-141-459-11 1-141-486-11 1-141-411-11

CAP, ADJ 20PF CAP, ADJ 20PF CAP, TRIMMER (SEAL TYPE) 45PF CAP, ADJ 10PF CAP, ADJ 20PF

< RESISTOR > R1 R2 R3 R4 R5

1-247-887-00 1-249-441-11 1-249-431-11 1-249-413-11 1-249-417-11


220K 100K 15K 470 1K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W F 1/4W F

R6 R7 R9 R10 R11

1-249-425-11 1-249-425-11 1-249-425-11 1-249-429-11 1-247-887-00


4.7K 4.7K 4.7K 10K 220K

5% 5% 5% 5% 5%

1/4W F 1/4W F 1/4W F 1/4W 1/4W

— 80 —

TUNER Ref. No.

Part No.

Description

R12 R13 R14 R19 R20

1-249-425-11 1-247-807-31 1-249-427-11 1-249-421-11 1-247-863-91


4.7K 100 6.8K 2.2K 22K

5% 5% 5% 5% 5%

1/4W F 1/4W 1/4W F 1/4W F 1/4W

Remarks

R21 R22 R23 R24 R25

1-249-404-00 1-249-429-11 1-249-421-11 1-249-429-11 1-249-429-11


82 10K 2.2K 10K 10K

5% 5% 5% 5% 5%

1/4W F 1/4W 1/4W F 1/4W 1/4W

R26 R27 R28 R29 R34

1-249-417-11 1-249-417-11 1-249-429-11 1-249-429-11 1-249-415-11


1K 1K 10K 10K 680

5% 5% 5% 5% 5%

1/4W F 1/4W F 1/4W 1/4W 1/4W F

R35 R36 R37 R38 R39

1-249-412-11 1-249-437-11 1-249-417-11 1-249-427-11 1-249-429-11


390 47K 1K 6.8K 10K

5% 5% 5% 5% 5%

1/4W F 1/4W 1/4W F 1/4W F 1/4W

R40 R42 R43 R44 R49

1-249-421-11 1-249-437-11 1-249-437-11 1-249-429-11 1-249-421-11


2.2K 47K 47K 10K 2.2K

5% 5% 5% 5% 5%

1/4W F 1/4W 1/4W 1/4W 1/4W F

R50 R51 R52 R53 R54

1-249-417-11 1-249-441-11 1-249-441-11 1-249-441-11 1-249-413-11


1K 100K 100K 100K 470

5% 5% 5% 5% 5%

1/4W F 1/4W 1/4W 1/4W 1/4W F

R55 R56 R57 R58 R59

1-249-437-11 1-249-411-11 1-247-791-91 1-247-883-00 1-249-421-11


47K 330 22 150K 2.2K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W F

R60 R70 R71 R72 R73

1-249-407-11 1-247-887-00 1-247-815-91 1-249-417-11 1-249-417-11


150 220K 220 1K 1K

5% 5% 5% 5% 5%

1/4W F 1/4W 1/4W 1/4W F 1/4W F

R75 R77

1-249-404-00 CARBON 1-249-429-11 CARBON

82 10K

5% 5%

1/4W F 1/4W

< VIBRATOR > X1 1-760-130-11 VIBRATOR, CRYSTAL (75kHz) *************************************************************

Ref. No.

Part No.

Description

Remarks

MISCELLANEOUS *************** 5 6 103 106 117

1-505-742-11 1-501-480-11 1-692-960-11 1-452-732-11 1-782-631-11

! 151 8-848-483-05 HRPE101 1-500-480-11 J301 1-566-891-11 M691 X-3374-291-1 M702 X-2625-769-1

SPEAKER (8CM) ANTENNA, TELESCOPIC SWITCH, PUSH (1 KEY) MAGNET WIRE, PARALLEL (FFC) (16 CORE) OPTICAL, PIC-UP KSS-213C/Q-RP HEAD, MAGNETIC (REC/PB/ERASE) JACK (H/P JACK) MOTOR ASSY GEAR ASSY (MB), MOTOR

! T901 1-431-483-11 TRANSFORMER, POWER (US,CND) ! T901 1-431-484-11 TRANSFORMER, POWER (AEP,IT,UK,E) ************************************************************* ACCESSORIES & PACKING MATERIALS ******************************** 1-590-147-11 1-690-952-21 1-696-820-21 1-770-019-11 3-704-222-11

! ! ! !

CORD, POWER (CND) CORD, POWER (US) CORD, POWER (AEP,IT,UK,E) ADAPTOR, CONVERSION PLUG 3P (UK) LABEL, SERIAL NUMBER (PRINTER)

3-860-693-11 MANUAL, INSTRUCTION (US,CND) (ENGLISH) 3-860-693-21 MANUAL, INSTRUCTION (CND) (FRENCH) 3-860-693-31 MANUAL, INSTRUCTION (AEP,UK,E) (ENGLISH,SPANISH) 3-860-693-41 MANUAL, INSTRUCTION (AEP,E) (FRENCH,GERMAN) 3-860-693-51 MANUAL, INSTRUCTION (AEP) (DUTCH,PORTUGUESE) 3-860-693-61 MANUAL, INSTRUCTION (AEP) (SWEDISH,FINNISH) 3-860-693-71 MANUAL, INSTRUCTION (IT) (ITALIAN) 4-991-047-01 LID, BATTERY CASE (FOR REMOTE COMMANDER) 8-917-611-90 REMOCON RMT-CD5AD SET (AEP,IT,UK,E) 8-917-612-90 REMOTE COMMANDER RMT-CD5A SET (US,CND) ************************************************************* ************** HARDWARE LIST ************** #1 #2 #3 #4 #5

7-685-647-79 7-685-535-14 7-685-533-14 7-682-549-09 7-685-649-79

SCREW +BVTP 3X10 TYPE2 IT-3 SCREW +BTP 2.6X10 TYPE2 N-S SCREW +BTP 2.6X6 TYPE2 N-S SCREW +B 3X10 SCREW +BVTP 3X14 TYPE2 N-S

#6 #7 #8

7-685-903-31 SCREW +PTPWH 3X10 TYPE2 7-685-533-19 SCREW +BTP 2.6X6 TYPE2 N-S 7-685-646-79 SCREW, TAPPING +BV 3X8


— 81 —


ZS-D5

Sony Corporation 9-923-270-11

Personal A&V Products Company

— 82 —

98C1690-1 Printed in Japan ©1998.3 Published by Quality Engineering Dept. (Shibaura)

ZS-D5

Ver 1.3 2000.2

US Model Canadian Model AEP Model UK Model E Model

SERVICE MANUAL 1998.11

SUPPLEMENT-1 File this supplement-1 with the Service Manual.

• The following parts are changed to the new parts from the serial numbers as described below. The new and former parts have different colors. (SPM-98011)

Destination US Model AEP Model UK Model E Model

Serial No. 7136231 to 7136531 to 7138299 to 7122176 to

: indicates changed portion Page

OLD Ref. No.

64

Part No.

NEW

Description

Remarks

Ref. No.

Description

Remarks

1

X-3375-238-1 CABINET SUB ASSY, FRONT

1

X-3376-357-1 CABINET SUB ASSY, FRONT

2

X-3375-236-1 HOLDER SUB ASSY, JACK

2

X-3376-361-1 HOLDER SUB ASSY, JACK

4

X-3375-239-1 HOLDER SUB ASSY, CASSETTE

4

X-3376-359-1 HOLDER SUB ASSY, CASSETTE

13

3-017-456-11 BUTTON, POWER (US,CND,E)

13

3-017-456-41 BUTTON, POWER (US,E)

13

3-017-456-21 BUTTON, POWER (AEP,IT,UK)

13

3-017-456-51 BUTTON, POWER (AEP,UK)

14

X-3375-237-1 BUTTON SUB ASSY, CONTROL

14

X-3376-363-1 BUTTON SUB ASSY, CONTROL

15

3-017-457-01 BUTTON, VOLUME

15

3-017-457-11 BUTTON, VOLUME

Sony Corporation 9-923-270-82

Part No.

Personal A&V Products Company

98K1690-1 Printed in Japan ©1998.11 Published by Quality Engineering Dept. (Shibaura)